No abstract

This study was undertaken to evaluate a pilot plant designed for sugarcane juice processing. The juice was extracted in an electric mill and acidified with citric acid until the pH of 4.3. Next, it was pasteurized in a plate heat exchanger at 95°C/30 sec, cooled to 10°C before being filled into a plastic bottle and induction sealed. Product filling was performed in an ISO class 5 unidirectional air-flow cabins. Three batches of acidified sugarcane juice were produced. The qualities of the raw material, rinse water of the processing and filling line, packaging and end product were all microbiologically evaluated. Hedonic scale tests were used to evaluate the sensory acceptance of the product. The total mean counts in mesophilic culture of molds and yeasts from the natural, fresh sugarcane juice were (6.26 and 5.20) log CFU/mL, respectively. These mean counts, in both rinse water samples of the processing line and the bottles, were lower than 1 log CFU/mL. The mean counts of molds and yeasts in acidified and pasteurized sugarcane juice were (2.63 and lower than 1) log CFU/mL, respectively. The findings indicated that the procedures that were evaluated met standards for acidified sugarcane juice to be produced then stored under refrigeration.

No abstract

The aim of this study was to investigate the effects of the use of chlorine or ozone as sanitizing agents in the water of chicken immersion chilling, using the residual levels usually applied in Brazil (1.5 ppm), comparing the effects of these treatments on the microbiological, physicochemical, and sensory characteristics of carcasses. Chicken carcasses were chilled in water (4°C) with similar residual levels of ozone and chlorine until reaching temperatures below 7°C (around 45 min). The stability of carcasses was assessed during 15 days of storage at 2 ± 1°C. Microbiological, surface color (L*, a*, b* parameters), pH value, lipid oxidation (thiobarbituric acid reactive substances index), and sensory evaluation (on a 9-point hedonic scale for odor and appearance) analyses were carried out. The presence of Salmonella was not detected, coagulase-positive staphylococci counts were below 10(2) CFU/ml of rinse fluid, and Escherichia coli and total coliform counts were below 10(5) CFU/ml of rinse fluid until the end of the storage period for both treatments. Psychrotrophic microorganism counts did not differ (P > 0.05) between chlorine and ozone treatments, and both values were near 10(9) CFU/ml of rinse fluid after 15 days at 4 ± 1°C. pH values did not differ between treatments (P > 0.05) or during the storage period (P > 0.05). In addition, neither chlorine nor ozone treatment showed differences (P > 0.05) in the lipid oxidation of carcasses; however, the thiobarbituric acid reactive substances index of both treatments increased (P ≤ 0.05) during the storage period, reaching values of approximately 0.68 mg of malonaldehyde per kg. Samples from both treatments did not differ (P > 0.05) in their acceptance scores for odor and overall appearance, but in the evaluation of color, ozone showed an acceptance score significantly higher (P ≤ 0.05) than that for the chlorine treatment. In general, under the conditions tested, ozone showed results similar to the results for chlorine in the disinfection of chicken carcasses in the immersion chilling, which may indicate its use as a substitute for chlorine in poultry slaughterhouses.

Três produtos comerciais de alimento com soja sabor laranja (A, B e C), acondicionados em embalagem longa vida, adquiridos no mercado foram avaliados sensorialmente. A Análise Descritiva Quantitativa (ADQ) foi utilizada para traçar os perfis sensoriais, avaliando-se doze atributos levantados por 10 julgadores selecionados e treinados. A aceitação dos produtos foi avaliada por 30 potenciais consumidores mediante Teste Afetivo, realizado em laboratório, utilizando-se escala hedônica estruturada mista de 9 pontos. Os resultados da ADQ foram submetidos à Análise de Variância (ANOVA), Teste de Média de Tukey e Análise de Componentes Principais, já os resultados do Teste Afetivo (Aceitação) foram analisados pela ANOVA e pelo Teste de Média de Tukey. Os produtos A e B ficaram mais próximos entre si, o produto C diferiu do produto B (significativamente ao nível de 5%) em todos os atributos, com exceção da doçura e amargor. Os produtos A e C diferiram em todos os atributos, com exceção do residual de edulcorante e viscosidade. No teste afetivo, o produto A obteve as maiores médias e notas dos julgadores, não diferindo do produto B em nenhum dos atributos analisados.