food industry market due to their wide application spectrum, in particular, to meet the daily growing demand of population in natural foods. This demand is caused by the rapid deterioration of the ecological state of many countries 1. Introduction Concentrated semi-finished products based on natural organic raw materials constitute a significant share of the

No abstract

This paper reports the results of studying the influence of two types of protein-mineral additives on the properties of butter biscuit emulsion. The additives are considered as a source of digestible calcium compounds and as a functional and technological component that can improve the quality of buttery flour products. The parameters for pre-hydration of additives in the environment of cow's milk for better implementation of their functional and technological characteristics have been substantiated. It was established that the use of protein-mineral additives in the manufacture of emulsions in the amount of up to 7 % leads to an increase in the emulsification capacity of model systems by 1.5...1.65 times. Improved emulsion resistance has been proven, in particular after heat treatment. It was established that using 5...7 % of the additive produces a pronounced thermal stabilizing effect. After heat treatment at a temperature of 90...95 °C during 3×60 s, when using the protein-mineral additive, a volume of the released water and fat phase increases by 12...25 %. When applying the improved additive, a volume of the released phases increases by 3...10 %. A lower degree of coalescence of the fat phase as part of the emulsion when using the improved protein-mineral additive was microscopically confirmed. The fact of increasing the effective viscosity of emulsions when using up to 7 % of the improved protein-mineral additive was established. This is a positive fact in terms of stabilizing the emulsions and improving their stability as one of the important factors related to the quality of finished flour confectionery. It was established that the improved form of the additive, due to the content of chondroitin sulfates, provides for a better effect on the characteristics of emulsions, which should have a positive influence on the quality of flour-based buttery products.

A formulation composition and a low-temperature technique have been devised for concentrating fruit and vegetable puree with the following component content: 20 % apple; 20 % pumpkin; 15 % beets; 15 % cranberries; 15 % hawthorn. The puree is concentrated in a rotary evaporator to a solids content of 50 % at a temperature of 50...56 °C under vacuum. The processing time was reduced to 1...2 min, which is several times less compared to conventional single-case pump vacuum evaporators (60...90 mins). Reducing the temperature influence of concentrating contributes to an increase in the organoleptic and physicochemical parameters of the resulting paste. To determine the effect of the contribution of each component to the structure of the paste, the structural and mechanical properties of the puree from each raw material and concentrated semi-finished products were investigated. The devised paste has an increased strength of the structure with a dynamic viscosity value of 394 Pa⋅s, which is 2.5 times more than that in the control sample. The devised blended fruit and vegetable paste has an increased content of physiologically functional ingredients and good organoleptic parameters, unlike control (apple paste). It was established that the partial replacement of apple puree in the formulation composition of marshmallow with 75 % of the devised multicomponent fruit and vegetable paste gives the product original properties. The dynamic viscosity value of the marshmallow in which 75 % of apple puree was replaced with the devised paste has increased, compared to the control sample (marshmallow without additives), from 408 Pa⋅s to 908 Pa⋅s. The color of the marshmallow mass where 75 % of apple puree were replaced is bright pink with a wavelength of 596.7 nm and a brightness of 62.3 %. The data reported here make it possible to improve the quality of original marshmallow products when adding fruit and vegetable semi-finished products whereby an increase in functional properties is provided

Technology and equipment of food production 49 tion dynamics over the last decade has revealed that the proportion of flour-based food products in the diet structure has grown significantly and continues to increase. Flour confectionery are an integral part of the consumer basket of