Design, performance characterization and hydrodynamic modeling of intermeshed spinning basket membrane (ISBM) module

Naskar, Mithu; Rana, Keka; Chatterjee, Deepangsu; Dhara, Trina; Sultana, Ruhi; Sarkar, Debasish

doi:10.1016/j.ces.2019.05.049

Cited by 9 publications

(8 citation statements)

References 53 publications

Supporting

Mentioning

Contrasting

Order By: Relevance

“…The same situation is observed for the tubular modules [127,137], and also for the multichannel ceramic modules [124] and similar designs [152]. Also, in some works the original designs were considered including rotating [90,142] and test and lab cells [98,135,143]. The works, in which the patterned [111] and corrugated [97] membrane surface, should be noticed individually.…”

Section: F15mentioning

confidence: 65%

Simulation of Reverse Osmosis Process: Novel Approaches and Development Trends

Huliienko

Korniyenko

Muzyka

et al. 2022

JES

View full text Add to dashboard Cite

Reverse osmosis is an essential technological separation process that has a large number of practical applications. The mathematical simulation is significant for designing and determining the most effective modes of membrane equipment operation and for a deep understanding of the processes in membrane units. This paper is an attempt at systematization and generalizing the results of the investigations dedicated to reverse osmosis simulation, which was published from 2011 to 2020. The main approaches to simulation were analyzed, and the scope of use of each of them was delineated. It was defined that computational fluid dynamics was the most used technique for reverse osmosis simulation; the intensive increase in using of molecular dynamics methods was pointed out. Since these two approaches provide the deepest insight into processes, it is likely that they will further be widely used for reverse osmosis simulations. At the same time, for the simulation of the membrane plant, it is reasonable to use the models that required the simplest solutions methods. The solution-diffusion model appears to be the most effective and flexible for these purposes. Therefore, this model was widely used in considering the period. The practical problems solved using each of the considered approaches were reviewed. Moreover, the software used for the solution of the mathematical models was regarded.

show abstract

Section: F15mentioning

confidence: 65%

Simulation of Reverse Osmosis Process: Novel Approaches and Development Trends

Huliienko

Korniyenko

Muzyka

et al. 2022

JES

View full text Add to dashboard Cite

show abstract

“…Maximum permeate flux was evaluated to be as high as 2.4×10 -4 m 3 /(m 2 s) at moderate transmembrane pressure and rotational speed (588 kPa and 52.36 rad/s). It also showed better performance in treating extremely fouling feed solutions than other standard membrane units [142,143].…”

Section: Rotating Rectangular Membranementioning

confidence: 95%

“…Most of tested fluids are biological suspensions ( fermentation broth ) containing microalgae [24,[108][109][110][111][112][113][114][115][116][117][118][119][120][121][122][123], yeast [19,[124][125][126][127][128][129][130][131][132][133][134], bacteria [135][136][137] and animal cell [138][139][140]. Other dispersions were produced by commercial or fermented biological products, including bovine serum albumin (BSA) [141][142][143], polygalacturonic acid 140, α-lactose monohydrate [144], ibuprofen [144], recombinant human growth hormone [145] and monoclonal antibody [146]. Within the research, 17 publications (40%) focused on the concentration and separation (biomass) of microalgae and constituted a new hotspot over the last decade.…”

Section: Bioprocess Engineeringmentioning

confidence: 99%

“…The empirical correlations between cake mass and operating conditions (TMP and wall shear stress) were reported and interpreted [112]. CFD has been combined with experimental data to investigate local operating conditions with biological fouling within DF devices [112,114,115,140,[142][143][144].…”

Section: Bioprocess Engineeringmentioning

confidence: 99%

“…In continuous running, the membrane filtration cycle rotated as a normal run, followed by a short time cleaning cycle rotated in the reverse direction. With the same theory, the intermeshed spinning basket membrane (ISBM) consists of two identical spinning baskets, which are intermeshed with a phase difference of 45° and able to operate at the same speed but in reverse direction [143]. Sarkar et al [50]investigated the separation of PEG 6000 with the SBM module and PES (5kDa) UF membrane.…”

Section: Rotating Rectangular Membranementioning

confidence: 99%

See 2 more Smart Citations