Nitrogen Oxides Reduction Effect and the Influence Mechanism of Exhaust Valve Lift on a Two-Stroke Marine Diesel Engine

Abstract

For the two-stroke marine diesel engine, the action of exhaust valve has a significant impact on scavenging and combustion processes and ultimately affects the engine performances and emissions. In order to reduce nitrogen oxides (NOx) emissions of a two-stroke marine diesel engine, different exhaust valve lifts (EVLs) were achieved by computational fluid dynamics simulation method in this study. The NOx reduction effect and influence mechanism of EVL on a two-stroke marine diesel engine were investigated in detail. The results showed that the in-cylinder residual exhaust gas and the internal exhaust gas recirculation (EGR) rate gradually increased with the decreasing EVL. Although the total mass of charge enclosed in the cylinder did not change much, the composition changed gradually and the maximum internal EGR rate reached 13.17% in this study. The maximum compression pressure and combustion pressure both rose first and then decreased with the decreasing EVL. While the start of combustion and the maximum combustion temperature were basically unaffected by EVL, the indicated power of the engine was also not much impacted when the EVL was changed from increasing 10 mm to decreasing 20 mm. The indicated specific fuel consumption first declined slowly and then rose rapidly as the EVL reduction exceeded 20 mm. NOx emissions decreased monotonously with the decreasing EVL. The reduction of NOx formation rate and the amount of NOx formation mass mainly occurred at the middle and late stages of combustion for the downward moving of residual exhaust gas. NOx emissions were reduced by 12.57% without compromising other engine performances at medium-reduced EVL in this study. However, in order to further reduce NOx emissions at low EVLs, other measures may be needed to make the residual exhaust gas more evenly distributed during the initial stage of combustion.

Multiple faults diagnosis for ocean-going marine diesel engines based on different neural network algorithms

“…The decrease in scavenging pressure will lead to an increase in internal exhaust gas recycling (EGR), the deterioration of combustion, and a decrease in the economy. 24,25 Low-efficiency air cooler: The internal blockage and scaling of the cooling water pipe in the air cooler will lead to a decrease in air cooler efficiency and an increase in intake air temperature. The rise of intake air temperature will not only reduce the intake fresh air mass but also may cause rough combustion, knock or even damage to the engine. The parameter settings of the five common single faults are shown in Table 3.…”

“…The decrease in scavenging pressure will lead to an increase in internal exhaust gas recycling (EGR), the deterioration of combustion, and a decrease in the economy. 24,25…”

“…In fact, the calculation process of the Hessian matrix is very complicated. The iteration step of the LM algorithm is shown in equations ( 24) and (25).…”