Tangential Flow Filtration of Colloidal Silver Nanoparticles: A “Green” Laboratory Experiment for Chemistry and Engineering Students

Abstract

Numerous nanoparticle (NP) fabrication methodologies employ "bottom-up" syntheses, which may result in heterogeneous mixtures of NPs or may require toxic capping agents to reduce NP polydispersity. Tangential flow filtration (TFF) is an alternative "green" technique for the purification, concentration, and size-selection of polydisperse NP suspensions or colloids, in that it allows for real-time analysis and reduces the usage of additional solvent and post-synthetic reagents. Upper-division undergraduate and graduate students in engineering and chemistry successfully applied a three-step TFF process to reduce the polydispersity of Creighton colloidal silver nanoparticles (AgNPs). UV−vis absorption spectroscopy in conjunction with the Lambert−Beer law and Mie's solutions to the Maxwell equations were employed to rapidly estimate the concentration and size of nanosilver in each TFF-fractionated colloidal sample using the localized surface plasmon resonance (LSPR) of AgNPs. A thorough emphasis on "green" nanochemistry and its underlying principles were also provided to educate the next generation of environmentally conscious nanochemists and nanoengineers for the ever-expanding nanosectors. The overall laboratory experience was perceived as intellectually stimulating and was highly rated in the student evaluations. This interdisciplinary experiment may be implemented in various nanotechnology, physical, or analytical courses.

Influence of natural organic matter on fate and transport of silver nanoparticles in saturated porous media: laboratory experiments and modeling

“…The XRD spectra of AgNPs confirmed the metallic composition (Supporting Information, Figure S3a). A UV-Vis absorption spectrophotometer was used to estimate the AgNP concentration using the SPR peak of AgNPs that was observed at 395 nm in good agreement with the literature (Lin et al 2011) and our recent report (Dorney et al 2014). The absorbance of AgNPs increased after the addition of 10 mg L -1 of NOM, and further addition of NOM (40, 80 and 160 mg L -1 ) decreased the AgNP absorbance.…”

Size Fractionation of Fluorescent Graphene Quantum Dots Using a Cross-Flow Membrane Filtration System

“…Components larger than membrane pores are retained and pass along the membrane surface, thus flowing back to the feed reservoir. This filtration mode could minimize membrane fouling and provides a stable flux compared to dead-end filtration [ 35 , 36 ]. For a given membrane filtration system and feed solution, cross-flow velocity is the primary parameter that determines mass transfer through the membrane [ 37 ].…”

Analytical‐Based Methodologies for Examining the In Vitro Absorption, Distribution, Metabolism, and Elimination (ADME) of Silver Nanoparticles

“…Metabolism (M): Recently, CPE was shown to facilitate the rapid differentiation of the two Ag species within biological (HepG2 cells) and environmental (solid wastewaters) matrices . This phase separation method is based on the selective abilities of: (a) Triton X‐114 (TX‐114) to form micelles with AgNPs above its cloud point (the detergent phase) and (b) salts like sodium thiosulfate (Na 2 S 2 O 3 ) or ethylenediaminetetraacetic acid (EDTA) to chelate Ag + and form hydrophilic complexes (the aqueous phase).…”