Aim:  To study the effect of antiseptics on bacterial biofilm formation. Methods and Results:  Biofilm formation and planktonic growth were tested in microtiter plates in the presence of antiseptics. For Escherichia coli G1473 in the presence of chlorhexidine or benzalkonium chloride, for Klebsiella pneumoniae CF504 in the presence of chlorhexidine and for Pseudomonas aeruginosa PAO1 in the presence of benzalkonium chloride, biofilm development and planktonic growth were affected at the same concentrations of antiseptics. For PAO1 in the presence of chlorhexidine and CF504 in the presence of benzalkonium chloride, planktonic growth was significantly inhibited by a fourfold lower antiseptic concentration than biofilm development. For Staphylococcus epidermidis CIP53124 in the presence of antiseptics at the minimal inhibitory concentration (MIC), a total inhibition of biofilm formation was observed. For Staph. epidermidis exposed to chlorhexidine at 1/2, 1/4 and 1/8 MIC, or to benzalkonium chloride at 1/8, 1/16 or 1/32 MIC, biofilm formation was increased from 11·4% to 22·5% without any significant effect onto planktonic growth. Conclusions:  Chlorhexidine and benzalkonium chloride inhibited biofilm formation of different bacterial species but were able to induce biofilm development for the Staph. epidermidis CIP53124 strain at sub‐MICs. Significance and Impact of the Study:  Sublethal exposure to cationic antiseptics may contribute to the persistence of staphylococci through biofilm induction.

In this study, the mechanical properties of biofilms formed at the surface of nano-filtration (NF) membranes from a drinking water plant were analysed. Confocal laser scanning microscopy observations revealed that the NF biofilms formed a dense and heterogeneous structure at the membrane surface, with a mean thickness of 32.5 +/- 17.7 mum. The biofilms were scraped from the membrane surface and analysed in rotation and oscillation experiments with a RheoStress 150 rotating disk rheometer. During rotation analyses, a viscosity decrease with speed of shearing characteristic of rheofluidification was observed (eta = 300 Pa s for ý = 0.3 s(-1)). In the oscillation analyses with a sweeping of frequency (1-100 Hz), elasticity (G') ranged from 3000 to 3500 Pa and viscosity (G'') from 800 to 1200 Pa. Creep curves obtained with an application of a shear stress of 30 Pa were viscoelastic in nature. The G(0) and eta values were, respectively, 1.4 +/- 0.3 x 10(3) Pa and 3.3 +/- 0.65 x 10(6) Pa s. The relationship between the characteristics of NF biofilms and the flow conditions encountered during NF is discussed.

No abstract

The nanofiltration (NF) drinking water production unit of the Mery-sur-Oise plant (Val d'Oise, France) consists of eight identical filtration trains composed of three stages positioned in steps for a production capacity of 140,000 m(3) day(-1). To gain a better understanding of the irreversible fouling of the NF membranes, spiral wound modules in operation for 8 years from each of the three stages of the plant were autopsied before and after chemical cleaning and analysis by Attenuated Total Reflection Fourier Transform Infrared spectroscopy, Inductive Coupled Plasma-Atomic Emission Spectrometry, contact angles, adenosine triphosphate (ATP) content measurements, and rheometry. The fouled membranes from the three stages had similar contact angles of approximately 60 degrees . Relative infrared signals typical of biofilms were classified in descending order from stage 1 to stage 3. The foulant matter of stages 1 and 2 contained similar but weaker ATP concentrations than stage 3. During rheometry experiments, rotation and oscillation analyses demonstrated that the biofilm of stage 3 was less viscous and less elastic than the biofilms of stages 1 and 2. After cleaning, all the parameters analyzed demonstrated a quantitative decrease in the fouling matter at the NF membrane surface, but a biofilm with intact viscoelastic properties (unchanged G' and G'' values) remained at the membrane surface for the three stages. The persistence of biofilm material with intact mechanical properties at the NF membrane surface after chemical cleaning may result in permanent permeability decreases.