One experiment was conducted to evaluate the influence of glycerin (GLY) on animal performance and health when used as a partial replacement for roughage in receiving diets. The second experiment was conducted using ruminally and duodenally cannulated steers in a 4 × 4 Latin square to determine the site of nutrient digestion and ruminal fermentation characteristics when GLY replaced roughage at 0%, 2.5%, 5%, and 10% of diet DM. In Exp. 1, steers (initial BW = 245 ± 2.3 kg) were fed treatment diets over a 42-d period that consisted of a control diet based on steam-flaked corn with GLY inclusion in replacement of dietary roughage at 0%, 5%, and 10% of diet DM. A linear reduction in DMI was observed as GLY increased (P = 0.01). Glycerin incorporation tended to improve G:F in a linear manner (P = 0.07); efficiency was improved 5.4% and 4.7% at 5% and 10% GLY. The number of animals receiving treatment for bovine respiratory disease did not differ among treatments. Furthermore, there were no differences among treatments for mortality or the frequency of steers that were seropositive for serum antibody titers to infectious bovine rhinotracheitis on d 28. In Exp. 2, apparent OM and apparent and true starch digestibility increased linearly (P < 0.05) as GLY concentration increased, whereas true OM digestibility responded in a quadratic (P < 0.01) manner. Bacterial OM and bacterial starch flow responded quadratically (P ≤ 0.02), and flow increased from 0% to 5% GLY inclusion and decreased thereafter. Feed OM flow responded quadratically (P ≤ 0.05), where it decreased from 0% to 2.5% GLY and increased from 2.5% to 10% GLY inclusion. Feed starch (P = 0.02) and total starch (P = 0.02) flow from the duodenum decreased linearly as the concentration of GLY increased in the diet. Bacterial N flow to the duodenum responded quadratically (P < 0.01); it increased with increasing GLY in the diet up to 5% and then decreased from 5% to 10%. The acetate to propionate (A:P) ratio in the ruminal fluid decreased (P < 0.05) as the concentration of GLY in the diet increased, which could have implications on improved G:F. The decrease in the A:P ratio as GLY increased in the diet, coupled with the linear decrease in DMI and improvement in G:F with GLY addition up to 5% of DM in place of roughage, implies that GLY is a viable dietary ingredient in growing and receiving diets.

The increased use of by-products in finishing diets for cattle leads to diets that contain greater concentrations of crude protein (CP) and metabolizable protein (MP) than required. The hypothesis was that excess dietary CP and MP would increase maintenance energy requirements because of the energy costs of removing excess N as urea in urine. To evaluate the potential efficiency lost, two experiments were performed to determine the effects of feeding excess CP and MP to calves fed a finishing diet at 1 × maintenance energy intake (Exp. 1) and at 2 × maintenance intake (Exp. 2). In each experiment, eight crossbred Angus-based steers were assigned to two dietary treatments in a switchback design with three periods. Treatments were steam-flaked corn-based finishing diets with two dietary protein concentrations, 13.8% CP/9.63% MP (CON) or 19.5% CP/14.14% MP (dry matter basis; ECP), containing corn gluten meal to reflect a diet with excess CP and MP from corn by-products. Each period was 27 d in length with a 19-d dietary adaptation period in outdoor individual pens followed by a 4-d sample collection in one of four open circuit respiration chambers, 2-d fast in outdoor pen, and 2-d fast in one of four respiration chambers. Energy metabolism, diet digestibility, carbon (C) and nitrogen (N) balance, oxygen consumption, and carbon dioxide and methane production were measured. At both levels of intake, digestible energy as a proportion of gross energy (GE) tended to be greater (P < 0.06) in ECP than in CON steers. Metabolizable energy (ME) as a proportion of GE tended to be greater (P = 0.08) in the ECP steers than in the CON steers at 2 × maintenance intake. At 1 × and 2 × maintenance intake, urinary N excretion (g/d) was greater (P < 0.01) in the ECP steers than the CON steers. Heat production as a proportion of ME intake at 1 × maintenance tended (P = 0.06) to be greater for CON than for ECP (90.9% vs. 87.0% for CON and ECP, respectively); however, at 2 × maintenance energy intake, it was not different (63.9% vs. 63.8%, respectively). At 1 × maintenance intake, fasting heat production (FHP) was similar (P = 0.45) for both treatments, whereas at 2 × maintenance intake, FHP tended to be greater (P = 0.09) by 6% in ECP than in CON steers. Maintenance energy requirements estimated from linear and quadratic regression of energy retention on ME intake were 4% to 6% greater for ECP than for CON. Results of these studies suggest that feeding excess CP and MP from a protein source that is high in ruminally undegradable protein and low in protein quality will increase maintenance energy requirements of finishing steers.

Abstract. Nitrous oxide (N2O) emission rates have traditionally been measured using non-flow-through (NFT), non-steady-state (NSS) chambers, which rely on measuring the increase in N2O concentration in the sealed chamber headspace over time. These flux measurements are very labor- and time-intensive, requiring three to four gas samples collected over a 30 to 60 min period, followed by laboratory N2O measurement with a gas chromatograph (GC) and subsequent flux rate calculation. The objective of this research was to develop and evaluate improved, real-time flux chamber designs that rapidly quantify N2O emissions from manure and soil. The first chamber system consisted of six square 0.95 m2 chamber pans. The chamber pans were mounted on a rail system to facilitate controlled indoor/outdoor laboratory research at a pilot scale. An aluminum lid was moved among the chamber pans. A second portable chamber system with a circular footprint (0.49 m internal dia.) was designed for use in field measurements. With both systems, N2O concentrations were measured each second with 0.1 ppb resolution by recirculating sample air through a real-time continuous N2O analyzer with return flow into the recirculating-flow-through (RFT-NSS) chamber. Performance and observational data are presented for different chamber vent designs, sealing mechanisms between the chamber pan and lid, recirculation pumps, and presence/absence of an internal fan that mixes headspace air within the sealed chamber. As examples of the repeatability and precision of the methodology, ten consecutive flux measurements were obtained using moist manure (32.6% wet basis water content, WCWB) within a 15 min period in which chamber pans were fitted with lids for 60 s and removed for 30 s. The mean calculated N2O flux was 43.08 ±0.89 mg N2O m-2 h-1. Using dry manure (WCWB = 10.8%), five consecutive flux measurements showed a very low, but consistent, flux that averaged 0.025 ±0.0016 mg N2O m-2 h-1. Five case study experiments demonstrate the usefulness of these chamber systems and highlight discoveries and lessons learned to enhance future research efforts. Major discoveries and observations include: (1) installation of a small internal fan within the chamber lids decreased N2O fluctuation over small time periods, allowing precise measurement of manure N2O fluxes as low as 0.0073 mg N2O m-2 h-1 during a 60 s measurement period; (2) two distinct N2O peaks were observed at 1 and 21 d following the addition of water to manure (initial WCWB = 32.6%), with the second peak accounting for 83% of the total N2O emitted over 45 d; and (3) there was notable diurnal variation in N2O fluxes due to temperature variation, even when the manure was dry (WCWB = 10.8%). These flux chamber systems proved to be more rapid, precise, and repeatable than traditional flux chamber methods and offer promise for future greenhouse gas emissions research on manure and soil. Keywords: Cattle, Chamber, Diurnal, Fan, Feedlot, Greenhouse gas, Manure, Precision.

Roughage is fed in finishing diets to promote ruminal health and decrease digestive upset, but the inclusion rate is limited because of the cost per unit of energy and feed management issues. Rumination behavior of cattle may be a means to standardize roughage in beef cattle finishing diets, and increasing the particle size of roughage could modulate the ruminal environment and aid in maintaining ruminal pH. Therefore, this experiment was conducted to determine the effects of corn stalk (CS) inclusion rate and particle size in finishing diets on digestibility, rumination, and ruminal fermentation characteristics of beef steers. Four ruminally cannulated steers were used in a 4 × 4 Latin square experiment. Treatments were arranged as a 2 × 2 factorial with treatments consisting of 5% inclusion of a short-grind roughage (5SG), 10% inclusion of a short-grind roughage (10SG), 5% inclusion of a long-grind roughage (5LG), and 10% inclusion of a long-grind roughage (10LG). Differences in particle size were obtained by grinding corn stalks once (LG) or twice (SG) using a commercial tub grinder equipped with a 7.6-cm screen and quantified using the Penn State Particle Separator (PSPS) to estimate physically effective NDF (peNDF). Each period included 14 d for adaptation and 4 d for diet, fecal, and ruminal fluid collections. Animals were outfitted with rumination monitoring collars to continuously measure rumination activity. The 10LG treatment had a greater ( < 0.01) percentage of large particles (retained on the top 3 sieves of the PSPS) compared to the other treatments. This resulted in a greater ( < 0.01) percentage of estimated peNDF for the 10LG diet compared to the others. Feeding diets containing 5% roughage tended to increase ( ≤ 0.09) DM, NDF, and starch total tract digestibility compared to diets containing 10% roughage. Cattle consuming LG treatments had greater ( < 0.01) rumination time and greater ( < 0.01) ruminal pH than cattle consuming diets containing SG roughage. Cattle receiving the 5% inclusion rate of roughage tended to have greater ( = 0.09) time (h/d) under a ruminal pH of 5.6 and a larger ( = 0.03) area under the threshold compared to cattle receiving the 10% roughage treatments. Overall, feeding a lower inclusion of roughage with a larger particle size may stimulate rumination and aid in ruminal buffering similar to that of a higher inclusion of roughage with a smaller particle size, without negatively impacting digestibility and fermentation.

Two hundred sixty-four crossbred heifers (initial BW = 354 kg ± 0.5) were used to determine effects of corn processing method and wet distillers grains plus solubles (WDGS) inclusion in finishing diets on animal performance, carcass characteristics, and manure characteristics. The study was conducted as a randomized complete block with a 2 × 2 factorial arrangement of treatments. Dietary treatments included steam-flaked corn (SFC)- and dry-rolled corn (DRC)-based finishing diets containing 0 or 20% WDGS (0SFC, 20SFC, 0DRC, and 20DRC, respectively). Heifers averaged 154 d on feed and were marketed in 3 groups. There were no interactions between corn processing method and WDGS detected (P ≥ 0.29) for any performance or carcass response variables. Heifers fed diets containing WDGS tended to have greater final BW (P = 0.10) and increased G:F (P = 0.08) compared with heifers fed diets without WDGS. Heifers fed SFC-based diets consumed 7% less feed (P< 0.01) and were 9% more efficient (P < 0.01) than heifers fed DRC-based diets. Carcass characteristics were not affected by corn processing method or WDGS inclusion (P ≥ 0.16). Intakes of OM, N, P, and K were greater (P ≤ 0.05) for heifers fed DRC-based diets than those fed SFC-based diets, which resulted in greater net accumulation of the nutrients in the manure (P ≤ 0.04). Heifers fed diets containing WDGS had greater (P < 0.01) intakes of N, P, and K than heifers fed diets without WDGS. As a result, a greater net accumulation of P and K (P ≤ 0.03) and N (P = 0.10) were present in the manure from cattle fed diets containing WDGS compared with those fed diets without WDGS. There was no interaction (P ≥ 0.16) between corn processing and WDGS on N volatilization losses. Nitrogen volatilization losses from manure (expressed as a percentage of intake and g·heifer(-1)·d(-1)) were greater (P < 0.01) for heifers fed SFC-based diets than heifers fed DRC-based diets. Feeding DRC-based finishing diets to heifers resulted in increased manure production and nutrient excretion and decreased N volatilization. Both corn processing method and WDGS inclusion affected animal performance and manure characteristics.