Maillard reaction products (MRPs) were prepared by reacting casein peptides with different concentrations of glucose at 80 °C for up to 12 h. The chemical properties of MRPs and their effects on lipid oxidation in fish oil-in-water emulsions were investigated. Increasing browning development and absorbance in 294 nm in the MRPs caused an increase in DPPH radical scavenging, but a decrease in iron chelation, which could be related to the loss of free amino groups in the peptides. The MRPs produced with longer reaction time or higher glucose concentrations were less effective in inhibiting lipid oxidation in emulsions at pH 7.0 compared to casein peptides alone. However, the antioxidant activity of MRPs in emulsions at pH 3.0 was not decreased by prolonged heating. The bitterness of MRPs was less than that of the original casein peptides, and bitterness decreased with increasing heating time and glucose concentrations. Therefore, the Maillard reaction was a potential method to reduce the bitterness of casein peptides while not strongly decreasing their antioxidant activity.

Recently, much attention has been given to improving the antioxidant activity of protein hydrolysates via the Maillard reaction, but little is known about the cellular antioxidant activity of Maillard reaction products (MRPs) from protein hydrolysates. We first investigated chemical characterization and the cellular antioxidant activity of MRPs in a shrimp (Litopenaeus vannamei) by-product protein hydrolysate (SBH)-glucose system at 110 °C for up to 10 h of heating. Solutions of SBH and glucose were also heated alone as controls. The Maillard reaction greatly resulted in the increase of hydroxymethylfurfural (HMF) and browning intensity, high molecular weight fraction, and reduction of the total amino acid in SBH with the heating time, which correlated well with the free radical scavenging activity of MRPs. MRPs had stronger inhibiting effects on oxidative stress of human HepG2 cells than the original SBH, and its cellular antioxidant activity strongly correlated with free radical scavenging activity, but less affected by the browning intensity and HMF level. The caramelization of glucose partially affected the HMF level and free radical scavenging activity of MRPs, but it was not related to the cellular antioxidant activity. The cellular antioxidant activity of MRPs for 5 h of heating time appeared to reach a maximum level, which was mainly due to carbonyl ammonia condensation reaction. In conclusion, the Maillard reaction is a potential method to increase the cellular antioxidant activity of a shrimp by-product protein hydrolysate, but the higher HMF levels and the lower amino acid content in MRPs should also be considered.