This study was undertaken to determine whether the incidence of either Salmonella spp. or Listeria monocytogenes on turkeys at three commercial processors could be related to the type of defeathering system: 1) conventional, 58 C common bath scald; 2) kosher, 7 C common bath scald; or 3) steam-spray, 62 C nonimmersion scald. Flocks were sampled before defeathering, after defeathering, and after chill at each facility. The incidence of Salmonella-positive turkeys significantly increased subsequent to conventional defeathering (10 positive out of 14) as compared with before defeathering (3/14). The number of Salmonella-positive carcasses following kosher (0/14) and steam-spray (2/14) defeathering were similar to the number of Salmonella-positive carcasses found prior to defeathering (1/14 and 3/14, respectively). The incidence of Salmonella-positive carcasses following chill was slightly lower, but not significantly different than the number of Salmonella-positive carcasses found immediately following defeathering at all processors (8/14, 0/14, 1/14 for conventional, kosher, and steam-spray processors, respectively). Although L. monocytogenes was detected on turkeys sampled before chilling (2/10, kosher) and after chilling (8/14, kosher; 1/14, conventional), no L. monocytogenes was detected on turkeys at any of the processors prior to the evisceration process. Flocks with high aerobic plate counts prior to processing were more likely to contain Salmonella-positive birds throughout processing. Aerobic plate counts of all flocks were similar after chill whether or not Salmonella spp. and L. monocytogenes were detected.

The cross-contamination effects of three commercial defeathering systems were compared using turkeys from a single Salmonella-positive flock (< or = 15% cloacal-positive). Single or "common" flocks were used to control flock-to-flock variability. Thirty birds were mechanically defeathered in each system as the first flock of the day and compared with 30 hand-defeathered (control) birds. Three trials, each using a different common flock, were completed. In Trial 1, the incidence of Salmonella-positive birds decreased following mechanical defeathering at all three processors. The incidence of Salmonella-positive carcasses in test flocks increased following steam-spray (approximately 100%) and kosher (approximately 50%) defeathering in Trials 2 and 3, whereas no increase in Salmonella-positive carcasses resulted from conventional defeathering. The decrease in the number of Salmonella-positive birds as a result of defeathering observed in Trial 1, as compared to increases observed in Trials 2 and 3, may be related to the selection of feather-contaminated (Trial 1) vs intestinal-colonized (Trials 2 and 3) turkeys. Surface temperature of the carcasses and length of time required to defeather were monitored within each system. It is hypothesized that the increases in the number of Salmonella-positive birds following steam-spray and kosher defeathering in Trials 2 and 3 were a result of skin surface changes occurring during the defeathering process, which allowed increased adherence or entrapment of Salmonella spp. on or within remaining skin layers.

The growth and carcass quality of adult channel catfish (176mm, 76g average length and weight) fed diets (6000 fish/diet) containing 14% and 28% dried, inedible whole egg were compared to similar fish fed a commercial or a formulated diet containing fish meal as the primary protein source. After 4 months, the fish fed 28% dried egg diet were S-8% longer and 17-31% heavier, and had consumed 0.06-1.111b feed per Ib weight gain less than fish fed the other diets. Fish fed the egg diets had 0.9-1.2% less dress-out and 0.3-2% more visceral cavity fat than fish fed the nonegg diets. Diets containing eggs did not affect the sensory quality or shear press values of the cooked fish fillets.