In cancer research and personalized medicine, new tissue culture models are needed to better predict the response of patients to therapies. With a concern for the small volume of tissue typically obtained through a biopsy, we describe a method to reproducibly section live tumor tissue to submillimeter sizes. These micro-dissected tissues (MDTs) share with spheroids the advantages of being easily manipulated on-chip and kept alive for periods extending over one week, while being biologically relevant for numerous assays. At dimensions below ~420 μm in diameter, as suggested by a simple metabolite transport model and confirmed experimentally, continuous perfusion is not required to keep samples alive, considerably simplifying the technical challenges. For the long-term culture of MDTs, we describe a simple microfluidic platform that can reliably trap samples in a low shear stress environment. We report the analysis of MDT viability for eight different types of tissues (four mouse xenografts derived from human cancer cell lines, three from ovarian and prostate cancer patients, and one from a patient with benign prostatic hyperplasia) analyzed by both confocal microscopy and flow cytometry over an 8-day incubation period. Finally, we provide a proof of principle for chemosensitivity testing of human tissue from a cancer patient performed using the described MDT chip method. This technology has the potential to improve treatment success rates by identifying potential responders earlier during the course of treatment and providing opportunities for direct drug testing on patient tissues in early drug development stages.

The cathepsin L propeptide (phcl-2) was expressed in Saccharomyces cerevisiae using a human procathepsin L/alpha-factor fusion construct containing a stop codon at position -1 (the C-terminal amino acid of the proregion). Since the yield after purification was very low, the cathepsin L propeptide was also obtained by an alternate procedure through controlled processing of an inactive mutant of procathepsin L (Cys25Ser/Thrl10Ala) expressed in Pichia pastoris, by small amounts of cathepsin L. The peptide resulting from the cleavage of the proenzyme (phcl-1) was then purified by HPLC. The purified propeptides were characterized by N-terminal sequencing and mass spectrometry and correspond to incomplete forms of the proregion (87 and 81 aa for phcl-1 and phcl-2 respectively, compared to 96 aa for the complete cathepsin L propeptide). The two peptides were found to be potent and selective inhibitors of cathepsin L at pH 5.5, with Ki values of 0.088 nM for phcl-1 and 0.66 nM for phcl-2. The Ki for inhibition of cathepsin S was much higher (44.6 nM with phcl-1), and no inhibition of cathepsin B or papain could be detected at up to 1 microM of the propeptide. The inhibitory activity was also found to be strongly pH-dependent. Two synthetic peptides of 75 and 44 aa corresponding to N-terminal truncated versions of the propeptide were also prepared by solid phase synthesis and displayed Ki values of 11 nM and 2900 nM, respectively, against cathepsin L. The data obtained for the 4 propeptide derivatives of various lengths indicate that the first 20 residues in the N-terminal region of the propeptide are more important for inhibition than the C-terminal region which contributes little to the overall inhibitory activity.

The main feature distinguishing cathepsin B from other cysteine proteases of the papain family is the presence of a large insertion loop, termed the occluding loop, which occupies the S' subsites of the enzyme. The loop is held in place mainly by two contacts with the rest of the enzyme, involving residues His110 and Arg116 on the loop that form salt bridges with Asp22 and Asp224, respectively. The influence of this loop on the endopeptidase activity of cathepsin B has been investigated using site-directed mutagenesis and internally quenched fluorogenic (IQF) substrates. Wild-type cathepsin B displays poor activity against the substrates Abz-AFRSAAQ-EDDnp and Abz-QVVAGA-EDDnp as compared to cathepsin L and papain. Appreciable increases in kcat/KM were observed for cathepsin B containing the single mutations D22A, H110A, R116A, and D224A. The highest activity however is observed for mutants where both loop to enzyme contacts are disrupted. For the triple-mutant D22A/H110A/R116A, an optimum kcat/KM value of 12 x 10(5) M-1 s-1 was obtained for hydrolysis of Abz-AFRSAAQ-EDDnp, which corresponds to a 600-fold increase relative to wild-type cathepsin B and approaches the level of activity observed with cathepsin L or papain. By comparison, the mutations have little effect on the hydrolysis of Cbz-FR-MCA. The influence of the mutations on the pH dependency of activity also indicates that the complexity of pH activity profiles normally observed for cathepsin B is related to the presence of the occluding loop. The major increase in endopeptidase activity is attributed to an increase in loop "flexibility" and suggests that the occluding loop might move when an endopeptidase substrate binds to the enzyme. The possible contribution of these interactions in regulating endopeptidase activity and the implications for cathepsin B activity in physiological or pathological conditions are discussed.