The overapplication of manure on agricultural soils leads to nitrogen and phosphorus discharge into the aquatic environment, resulting in serious eutrophication problems and decreased water quality. Piggery wastewater (PWW) can be treated by microalgae to recycle nutrients, but the toxic levels of ammonia and organic matter hinder their growth. Fresh water is usually used to dilute PWW, but it is a scarce resource. The implementation of a pretreatment step before microalgae-based treatment could make PWW suitable for microalgae growth. Electrocoagulation, ammonia stripping, photo-Fenton, and constructed wetlands were evaluated as pretreatment methods to reduce ammonia, chemical oxygen demand (COD), color, and total suspended solids. Moreover, the pretreated PWWs were tested to grow the microalga Tetradesmus obliquus. Photo-Fenton showed the best results among the other pretreatments, achieving removal efficiencies above 90%, except for ammonia. This resulted in T. obliquus being capable of growing on undiluted PWW, even at higher ammonia levels, achieving similar biomass productivity to synthetic medium (66.4 ± 17.8 mg·L−1·day−1 and 60.1 ± 10.4 mg·L−1·day−1, respectively) almost doubling with pH control (116.5 mg·L−1·day−1). Thus, this pretreatment seems to be the most promising one to incorporate into microalgae-based treatment systems and must be further explored.

Microalgae have almost unlimited applications due to their versatility and robustness to grow in different environmental conditions, their biodiversity and variety of valuable bioactive compounds. Wastewater can be used as a low-cost and readily available medium for microalgae, while the latter removes the pollutants to produce clean water. Nevertheless, since the most valuable metabolites are mainly located inside the microalga cell, their release implies rupturing the cell wall. In this study, Tetradesmus obliquus grown in 5% piggery effluent was disrupted using high-pressure homogenization (HPH). Effects of HPH pressure (100, 300, and 600 bar) and cycles (1, 2 and 3) were tested on the membrane integrity and evaluated using flow cytometry and microscopy. In addition, wheat seed germination trials were carried out using the biomass at different conditions. Increased HPH pressure or number of cycles led to more cell disruption (75% at 600 bar and 3 cycles). However, the highest increase in wheat germination and growth (40–45%) was observed at the lowest pressure (100 bar), where only 46% of the microalga cells were permeabilised, but not disrupted. Non-treated T. obliquus cultures also revealed an enhancing effect on root and shoot length (up to 40%). The filtrate of the initial culture also promoted shoot development compared to water (21%), reinforcing the full use of all the process fractions. Thus, piggery wastewater can be used to produce microalgae biomass, and mild HPH conditions can promote cell permeabilization to release sufficient amounts of bioactive compounds with the ability to enhance plant germination and growth, converting an economic and environmental concern into environmentally sustainable applications.