Despite their broad clinical use, there is no standardized comparative study on the functional, biochemical, and morphologic differences of the various commercial surfactants in relation to native surfactant. We investigated these parameters in Alveofact, Curosurf, Exosurf, and Survanta, and compared them with native bovine (NBS) and porcine (NPS) surfactant. For Curosurf and Alveofact the concentrations necessary for minimal surface tensions < 5 mN/m were six to 12 times higher (1.5 and 3 mg/ml, respectively) than with NPS and NBS. Exosurf and Survanta only reached 22 and 8 mN/m, respectively. Increasing calcium to nonphysiologic concentrations artificially improved the function of Alveofact and Curosurf, but it had little effect on Exosurf and Survanta. Impaired surface activity of commercial versus native surfactants corresponded with their lack in surfactant protein SP-A and decreased SP-B/C. The higher surface activity of Curosurf compared with Alveofact corresponded with its higher concentration of dipalmitoylphosphatidylcholine (DPPC). Despite their enrichment in DPPC Survanta and Exosurf exhibited poor surface activity because of low or absent SP-B/C. Ultrastructurally, Curosurf and Alveofact consisted mainly of lamellar and vesicular structures, which were also present in NPS and NBS. Exosurf contained crystalline structures only, whereas the DPPC-enriched Survanta contained separate lamellar/vesicular and crystalline structures. We conclude that in vitro surface activity of commercial surfactants is impaired compared with native surfactants at physiologic calcium concentrations. In the presence of SP-B/C, surface activity corresponds to the concentration of DPPC. Our data underscore the importance of a standardized protocol at physiologic calcium concentrations for the in vitro assessment of commercial surfactants.

To study the effects of apneic pauses, sighs, and breathing patterns on functional residual capacity (FRC), we measured FRC repeatedly in 48 healthy preterm infants (weight at study 2,042 +/- 316 g [mean +/- SD], postconceptional age 36.6 +/- 2.0 wk), during unsedated sleep using a modified heliox/nitrogen washout technique. Breathing movements and pulse oximeter saturation (SpO2) were recorded throughout and recordings analyzed for the presence of regular and nonregular breathing pattern, apneic pauses, sighs, and desaturations (SpO2 < 90%) during the last 2 min prior to each FRC measurement. FRC was lower during nonregular than during regular breathing pattern (23.3 +/- 7.2 ml/kg versus 26.9 +/- 7.8 ml/kg, p < 0.02); however, this apparent effect of breathing pattern disappeared after controlling the data for apneic pauses. Apneic pauses resulted in a significant decrease in FRC: mean FRC was 20.0 +/- 6.8 ml/kg if measured within 2 min of an apneic pause, 26.0 +/- 6.9 ml/kg if measured after a sigh (p < 0.001), and 24.0 +/- 7.7 ml/kg if there had been neither a sigh nor an apneic pause (p < 0.05). The interval between the apneic pause and the FRC measurement had no effect on FRC. There was an inverse correlation between FRC and the speed with which SpO2 fell during desaturation (r = -O.5, p < 0.03). Apneic pauses resulted in a persistent reduction in FRC in these preterm infants. Sighs appeared to restore FRC. The significant relationship between FRC and the speed of desaturation found in this study underscores the importance of endogenous or exogenous strategies that help to increase FRC, such as sighs or the application of continuous positive airway pressure, for the stability of oxygenation in preterm infants who have difficulty maintaining their oxygenation.

As birds have tubular lungs that do not contain alveoli, avian surfactant predominantly functions to maintain airflow in tubes rather than to prevent alveolar collapse. Consequently, we have evaluated structural, biochemical, and functional parameters of avian surfactant as a model for airway surfactant in the mammalian lung. Surfactant was isolated from duck, chicken, and pig lung lavage fluid by differential centrifugation. Electron microscopy revealed a uniform surfactant layer within the air capillaries of the bird lungs, and there was no tubular myelin in purified avian surfactants. Phosphatidylcholine molecular species of the various surfactants were measured by HPLC. Compared with pig surfactant, both bird surfactants were enriched in dipalmitoylphosphatidylcholine, the principle surface tension-lowering agent in surfactant, and depleted in palmitoylmyristoylphosphatidylcholine, the other disaturated phosphatidylcholine of mammalian surfactant. Surfactant protein (SP)-A was determined by immunoblot analysis, and SP-B and SP-C were determined by gel-filtration HPLC. Neither SP-A nor SP-C was detectable in either bird surfactant, but both preparations of surfactant contained SP-B. Surface tension function was determined using both the pulsating bubble surfactometer (PBS) and capillary surfactometer (CS). Under dynamic cycling conditions, where pig surfactant readily reached minimal surface tension values below 5 mN/m, neither avian surfactant reached values below 15 mN/m within 10 pulsations. However, maximal surface tension of avian surfactant was lower than that of porcine surfactant, and all surfactants were equally efficient in the CS. We conclude that a surfactant composed primarily of dipalmitoylphosphatidylcholine and SP-B is adequate to maintain patency of the air capillaries of the bird lung.

Surfactant reduces surface tension at the air-liquid interface of lung alveoli. While dipalmitoylphosphatidylcholine (PC16:0/ 16:0) is its main component, proteins and other phospholipids contribute to the dynamic properties and homeostasis of alveolar surfactant. Among these components are significant amounts of palmitoylmyristoylphosphatidylcholine (PC16:0/ 14:0) and palmitoylpalmitoleoylphosphatidylcholine (PC16:0/ 16:1), whereas in surfactant from the rigid tubular bird lung, PC16:0/14:0 is absent and PC16:0/16:1 strongly diminished. We therefore hypothesized that the concentrations of PC16:0/14:0 and PC16:0/16:1 in surfactants correlate with differences in the respiratory physiology of mammalian species. In surfactants from newborn and adult mice, rats, and pigs, molar fractions of PC16:0/14:0 and PC16:0/16:1 correlated with respiratory rate. Labeling experiments with [methyl-(3)H]choline in mice and perfused rat lungs demonstrated identical alveolar proportions of total and newly synthesized PC16:0/14:0, PC16:0/16:1, and PC16:0/16:0, which were much higher than those of other phosphatidylcholine species. In surfactant from human term and preterm neonates, fractional concentrations not only of PC16:0/16:0 but also of PC16:0/14:0 and PC16:0/ 16:1 increased with maturation. Our data emphasize that PC16:0/14:0 and PC16:0/16:1 may be important surfactant components in alveolar lungs, and that their concentrations are adapted to respiratory physiology.

Surfactant composition and function differ between vertebrates, depending on pulmonary anatomy and respiratory physiology. Because pulmonary development in pigs is similar to that in humans, we investigated surface tension function, composition of phospholipid molecular species, and concentrations of surfactant protein (SP)-A to -D in term newborn pigs (NP) compared with adolescent pigs (AP), using the pulsating bubble surfactometer, mass spectrometry, high-performance liquid chromatography, and immunoblot techniques (IT). NP was more potent than AP surfactant in reaching minimal surface tension values near zero mN/m. Whereas SP-A and SP-D were comparable, SP-B and SP-C were increased 3- to 4-fold in NP surfactant. Moreover, fluidizing phospholipids such as palmitoylmyristoyl-PC (PC16:0/14:0) and palmitoylpalmitoleoyl-PC (PC16:0/16:1) were increased at the expense of PC16:0/16:0 (32.4 +/- 0.6 versus 44.5 +/- 3.2%, respectively). Whereas concentrations of total anionic phospholipids were similar in NP and AP surfactant (9.9 +/- 0.3 and 12.0 +/- 0.3%, respectively), phosphatidylinositol was the predominant anionic phospholipid in NP surfactant. We conclude that, compared with AP, NP surfactant displays better surface tension function under dynamic conditions, which is associated with increased concentrations of SP-B and SP-C, as well as fluidizing phospholipids at the expense of PC16:0/16:0.