A novel long-lasting repellent-treated net (LLRTN) has been designed by binding the skin repellents N,N-diethyl-m-toluamide (DEET), or IR3535, onto the fibres of bed net fabric using a new polymer-coating technique. The repellent toxicological effectiveness and residual activity of a factory-based repellent-impregnated fabric has been evaluated by laboratory testing against adult Aedes aegypti mosquitoes and nymphal Ixodes ricinus ticks. By using this repellent-embedding impregnation technique, concentrations exceeding 10 g/m(2) could be achieved with one single polymer layer. Both DEET- and IR3535-impregnated fabrics revealed a dose-dependent insecticidal as well as acaricidal activity. One hundred percent knockdown times of DEET-treated bed nets ranged from 187.5 +/- 31.8 to 27.5 +/- 3.5 min against A. aegypti, and between 214 +/- 47 and 22.6 +/- 5 min against nymphal I. ricinus, linked to a DEET concentration of 1.08 and 10.58 g/m(2), respectively. With IR3535, A. aegypti produced dose-dependent 100% knockdown times varying from 87.5 +/- 10.6 to 57.5 +/- 3.5 min and between 131.4 +/- 6.5 and 33.8 +/- 5 min against nymphal I. ricinus, respectively, linked to concentrations between 1.59 and 10.02 g/m(2). One hundred percent repellency measured by complete landing and biting protection of impregnated fabric by using the arm-in-cage test could be achieved at DEET concentrations exceeding 3.7 to 3.9 g/m(2), and for IR3535 concentrations over 10 g/m(2). One hundred percent landing and biting protection could be preserved with DEET-treated fabrics for 29 weeks at an initial concentration of 4.66 g/m(2), 54 weeks at 8.8 g/m(2), 58 weeks at 9.96 g/m(2) and 61 weeks at 10.48 g/m(2) for DEET, and 23 weeks for IR3535-treated fabric at a concentration of 10.02 g/m(2). Unlike repellent-treated fabric, a brand of a commercially available long-lasting insecticide-treated net tested containing 500 mg permethrin/m(2) did not protect from mosquito bites. First results on bioactivity and long-lasting efficacy show that the new LLRTN technique is highly promising as a potential candidate for future malaria control strategies, especially in areas where pyrethroid resistance occurs.

A novel long-lasting insecticide-treated net (LLIN) has been designed by embedding the pyrethroids deltamethrin, cyfluthrin, permethrin, or etofenprox, onto the fibres of bed net cotton fabric by transferring a new polymer-coating technique from clothing to netting material. EN ISO 6330, the more stringent European Norm for domestic washing and drying procedures for textile testing, has been newly employed to monitor and validate more precise wash durability and residual bioactivity of LLINs. Wash durability, residual insecticidal activity and mosquito landing/biting protection has been investigated and compared with four commercially available LLINs. The pyrethroid-embedding impregnation technique allows binding of high concentrations exceeding 8,000 mg permethrin/m(2) within one single-polymer layer. Recovery rates of 95.7 ± 5.8%, 92.4 ± 14.0%, 70.2 ± 9.1%, and 64.2 ± 6.3% for cyfluthrin; 32.4 ± 11.4%, 32.4 ± 12%, 35.1 ± 16.2%, and 35.8 ± 15.7% for deltamethrin; 75.3 ± 12.9%, 57.1 ± 15.8%, 48.5 ± 4.0%, and 35.6 ± 4.7% for etofenprox; and 95.7 ± 5.8%, 80.2 ± 8.6%, 39.1 ± 7.9%, and 34.1 ± 8.8% were measured after 1, 5, 10, and 20 launderings. Laundering resistance was highest with cyfluthrin > deltamethrin ≈ etofenprox ≈ permethrin. After one and five launderings, commercial LLINs revealed percentage pyrethroid recovery rates of 26.3 ± 11.8% and 0.9 ± 1.2% for the Care Plus(®) net; 31.8% and 28.9% for the Permanet(®) 2.0; 61.4% and 45.6% for the Net Protect(®); and 80.4% and 68.3% for the Conmanet(®). Recovery rates reveal that the polymer-coating method resulted in extended wash durability. Dose-dependent 100% knockdown rates were most effective with deltamethrin > cyfluthrin > permethrin ≈ etofenprox. LLINs tested at concentrations up to 8,000 mg permethrin/m(2) did not protect from mosquito bites. Results on long-lasting efficacy and bioactivity of the polymer-coating technique show that this new LLIN technique is a highly promising potential candidate for future malaria control strategies. Standardized machine laundering and drying according to EN ISO 6330 is highly recommended to monitor and validate wash durability and residual activity of LLINs.