No abstract

Transition towards plant-based diets is advocated to reduce the climate footprint. Health implications of a diet composed of meat substitutes are currently unknown, and there are knowledge gaps in their nutritional composition and quality. Samples of available meat substitutes were bought in two convenience stores in the city of Gothenburg, Sweden, and were included in the study. Meat substitutes (n = 44) were analyzed for their contents of dietary fiber, fat, iron, zinc, phytate, salt, total phenolics and protein, as well as for their amino acid and fatty acid composition. Bioavailability of iron and zinc was estimated based on the phytate:mineral molar ratio. We found large variations in the nutritional composition of the analyzed meat substitutes. Amino acid profiles seemed to be affected by processing methods. Mycoprotein products were rich in zinc, with a median content of 6.7 mg/100 g, and had very low content of phytate, which suggests mycoprotein as a good source of zinc. Degradability of fungal cell walls might, however, pose as a potential aggravating factor. None of the products could be regarded as a good source of iron due to very high content of phytate (9 to 1151 mg/100 g) and/or low content of iron (0.4 to 4.7 mg/100 g). Phytate:iron molar ratios in products with iron contents >2.1 mg/100 g ranged from 2.5 to 45. Tempeh stood out as a protein source with large potential due to low phytate content (24 mg/100 g) and an iron content (2 mg/100 g) close to the level of a nutrition claim. Producers of the products analyzed in this study appear to use nutritional claims regarding iron that appear not in line with European regulations, since the iron is in a form not available by the body. Meat substitutes analyzed in this study do not contribute to absorbed iron in a relevant manner. Individuals following mainly plant-based diets have to meet their iron needs through other sources. Salt and saturated fat were high in certain products, while other products were more in line with nutritional recommendations. Further investigation of the nutritional and health effects of protein extraction and extrusion is needed. We conclude that nutritional knowledge needs to be implemented in product development of meat substitutes.

During the production of industrial hempseed oil, a press cake is formed as a byproduct, which is often used as animal feed although it contains a high amount of protein that could be used for human consumption. Extracting this valuable protein would reduce food waste and increase the availability of plant‐based protein. A protein extraction process based on the pH‐shift method was adapted to improve the protein extraction yield from industrial hempseed press cake (HPC). Parameters such as alkali extraction pH, time, and temperature, as well as isoelectric precipitation pH, were investigated in laboratory scale and were thereafter carried out in a pilot trial to explore the suitability for future scale up. The phytic acid content of the extracted protein isolate was also analyzed to investigate any potential inhibitory effect on mineral absorption. A final protein yield of 60.6%, with a precipitated protein content of 90.3% (dw), was obtained using a constant alkali extraction pH of 10.5 for 1 h at room temperature, followed by precipitation at pH 5.5. The pilot trial showed promising results for the future production of industrial hemp protein precipitate on a larger scale, showing a protein yield of 57.0% and protein content of 90.8% (dw). The amount of phytic acid in the protein isolate produced in the optimal laboratory experiment and in the pilot trial was 0.595 and 0.557 g phytic acid/100 g dw, respectively, which is 83%–88% less than in the HPC. This is in the range of other plant‐based protein sources (tofu, kidney beans, peas, etc.). Practical Application Industrial hempseed press cake is a byproduct in the production of industrial hempseed oil, which is mostly used as animal feed, but has the potential to become an additional source of plant‐based protein for human consumption with a suitable protein extraction method. The extracted hemp protein could be used to develop new plant‐based dairy or meat analog products.

Meat analogs based on plant protein extracts are rising in popularity as meat consumption declines. A dietary shift away from meat, which has a high iron bioavailability, may have a negative effect on the amount of iron absorbed from the diet. Iron absorption from legumes cultivated in regions not suitable for soy production, such as fava bean, has not yet been explored. The aim of this study was to evaluate non-heme iron absorption from a meal with texturized fava bean protein compared to beef and cod protein meals. The study included two single-blinded iron isotope trials in healthy Swedish women of the ages 18–45 years, each of whom served as their own control. The participants were served matched test meals containing beef and fava bean protein (Study 1) or cod and fava bean protein (Study 2) with radiolabeled non-heme iron 55Fe and 59Fe. The absorption of non-heme iron from test meals was measured by whole-body counting and erythrocyte incorporation. The absorption of non-heme iron, measured as erythrocyte incorporation ratio, from beef protein meal was 4.2 times higher compared to texturized fava bean meal, and absorption from cod protein meal was 2.7 times higher compared to the fava bean meal. The adjusted non-heme iron absorption, normalized to a 40% reference dose uptake, was 9.2% for cod protein meal, 21.7% for beef protein meal, and 4.2% for texturized fava bean meal. A fava bean protein meal has markedly lower iron bioavailability in healthy females compared with a meal of beef or cod protein. Therefore, a dietary shift from meat and fish protein to fava bean protein may increase the risk of iron deficiency.

Background: The non-dairy sector is growing, fermented alternatives to dairy are sparse. Adapted starter cultures to substituting raw materials needs to be developed. Objective: Aims of this study were to isolate, identify, and phenotypically characterize lactic acid bacteria (LAB) that inhabit Swedish legumes, and assess properties necessary for selecting strains with the ability to ferment a bean beverage and with potential health beneficial properties. Design: Isolates of presumed LAB were obtained from legumes collected at Öland, Sweden. Strain diversity was assessed by repetitive polymerase chain reaction (rep-PCR). The strains were identified using matrix-assisted laser desorption/ionization-time-of-flight mass spectrometry (MALDI-TOF MS). Species belonging to Enterococcus were predominant along with Pediococcus and closely related Bacillus. Strains were tested for tolerance to low pH, phenol, and bile as well as their bile salt hydrolase (BSH) activity. In addition, Enterococcus strains were tested for antibiotic resistance, and Pediococcus strains for their ability to ferment a bean beverage. Results: From the 25 strains char acterized, five were found resistant to low pH, bile, and phenol, suggesting that they can survive a passage through the gastrointestinal tract (GIT) and hence potentially exert beneficial effects in the host. These are suggested for further investigation on specific host-beneficial properties. Two of these, belonging to Pediococ cus pentosaceus, were able to ferment a bean beverage without any added nutrients, indicating that the Pediococcus strains are well adapted to the bean substrate. One of the P. pentosaceus strains were also able to markedly improve the reduction of phytate by the phytase-producing yeast strain Pichia kudriavzevii TY1322 during co-fermentation as well as increase the final cell count of the yeast strain. Conclusion: Strain isolation and characterization performed in this study aids in selecting starter cultures for legume fermentation. Nutritional properties can be improved by co-fermentation with yeast indicating that novel nutritious fermented non-dairy products could be developed.