The objectives of this work were to evaluate infrared (IR) dry blanching in comparison with conventional water blanching prior to hot air drying of mango to inactivate polyphenol oxidase (PPO) and ascorbic acid oxidase (AAO) enzymes, and to study its effect on color change and retention of vitamin C and β-carotene. Mango cylinders were blanched under similar temperature-time conditions either by IR heating or by immersion in a water bath during 2 min at 90 °C (high-temperature-short-time-HTST) or for 10 min at 65 °C (low-temperature-long-time-LTLT). After blanching mango was hot air dried at 70 °C. PPO was completely inactivated during the blanching treatments, but AAO had a moderate remaining activity after LTLT treatment (∼30%) and a low remaining activity after HTST treatment (9% to 15%). A higher retention of vitamin C was observed in mango subjected to IR dry blanching, 88.3 ± 1.0% (HTST) and 69.2 ± 2.9% (LTLT), compared with water blanching, 61.4 ± 5.3% (HTST) and 50.7 ± 9.6% (LTLT). All-trans-β-carotene retention was significantly higher in water blanched dried mango, 93.2 ± 5.2% (LTLT) and 91.4 ± 5.1% (HTST), compared with IR dry blanched, 73.6 ± 3.6% (LTLT) and 76.9 ± 2.9% (HTST). Increased levels of 13-cis-β-carotene isomer were detected only in IR dry blanched mango, and the corresponding dried mango also had a slightly darker color. IR blanching of mango prior to drying can improve the retention of vitamin C, but not the retention of carotenoids, which showed to be more dependent on the temperature than the blanching process. A reduction of drying time was observed in LTLT IR-blanching mango.

The impact of acidification with citric acid, addition of EDTA or water blanching at high temperature, and short time (HTST) conducted at 90°C for 4 min, on the retention of vitamin C (L-AA and DHAA) and β-carotene was studied in mango purée 30 min after crushing. HTST blanching prior to matrix disruption into purée resulted in complete inactivation of polyphenol oxidase (PPO) and minor residual activity (8%) of ascorbic acid oxidase (AAO). The retention of total vitamin C was 100% in blanched purées and in purée with EDTA and about 90% in purées at pH 3.9 and 5.0. Acidification, blanching, and addition of EDTA preserved vitamin C mainly as L-AA, while complete conversion into DHAA was observed in purée at pH 5.0. The retention of all-trans-β-carotene was between 65 and 72%, with the highest value in purée with EDTA and the lowest value in purée of blanched mango. The ratio of 13-cis-β-carotene in fresh mango was 8.2 ± 0.5% that increased significantly after blanching and in purée at pH 5.0. 707

No abstract

No abstract