In 1998, Countdown Downunder, Australia's national mastitis and cell count control programme, was created. With funding from the country's leading dairy organisation, Dairy Australia, this programme was originally intended to run for three years but is now in its tenth year. As it was the first time Australia had attempted a national approach to mastitis control on the farm, the first three years of the programme were largely concerned with the development of resources to be used by farmers and service providers. The second three years were devoted to training with both groups. Since that time, Countdown Downunder has entered into a second resource development phase. The goal of the programme was to achieve a reduction in the bulk milk somatic cell count from the Australian dairy herd. To achieve this, the programme had to develop resources with clear and consistent messages around mastitis and somatic cell count control on farms. It was determined that progress toward the goals would be made more rapidly if service providers were trained in the use of these resources prior to farmers. This paper reviews the Countdown Downunder programme from 1998 to 2007.

The primary objective of this experiment was to assess the effect of mouthpiece chamber vacuum on teat-end congestion. The secondary objective was to assess the interactive effects of mouthpiece chamber vacuum with teat-end vacuum and pulsation setting on teat-end congestion. The influence of system vacuum, pulsation settings, mouthpiece chamber vacuum, and teat-end vacuum on teat-end congestion were tested in a 2×2 factorial design. The low-risk conditions for teat-end congestion (TEL) were 40 kPa system vacuum (Vs) and 400-ms pulsation b-phase. The high-risk conditions for teat-end congestion (TEH) were 49 kPa Vs and 700-ms b-phase. The low-risk condition for teat-barrel congestion (TBL) was created by venting the liner mouthpiece chamber to atmosphere. In the high-risk condition for teat-barrel congestion (TBH) the mouthpiece chamber was connected to short milk tube vacuum. Eight cows (32 quarters) were used in the experiment conducted during 0400 h milkings. All cows received all treatments over the entire experimental period. Teatcups were removed after 150 s for all treatments to standardize the exposure period. Calculated teat canal cross-sectional area (CA) was used to assess congestion of teat tissue. The main effect of the teat-end treatment was a reduction in CA of 9.9% between TEL and TEH conditions, for both levels of teat-barrel congestion risk. The main effect of the teat-barrel treatment was remarkably similar, with a decrease of 9.7% in CA between TBL and TBH conditions for both levels of teat-end congestion risk. No interaction between treatments was detected, hence the main effects are additive. The most aggressive of the 4 treatment combinations (TEH plus TBH) had a CA estimate 20% smaller than for the most gentle treatment combination (TEL plus TBL). The conditions designed to impair circulation in the teat barrel also had a deleterious effect on circulation at the teat end. This experiment highlights the importance of elevated mouthpiece chamber vacuum on teat-end congestion and resultant decreases in CA.

The primary aim of this study was to assess the effects of incomplete milking on milk secretion and milk composition at the quarter level. Twelve cows were enrolled beginning at 5 d in milk and remained on study through 47 d in milk. Half of each contralateral udder was incompletely milked (treatment), detaching the teat cup early to leave approximately 30% of the total milk yield behind. This target milk remaining in the gland was based on weekly calibration milking measurements of quarter total milk yield. Control quarters were milked completely until milk flow had decreased to 0 kg/min based on visual assessment. Harvested milk yield was measured twice daily at each milking, and milk components (fat, protein, lactose, solids nonfat, milk urea nitrogen) and somatic cell count, were measured twice weekly at the quarter level. The experimental unit in this design was the half-udder, and a mixed-model approach was used to assess the main and interactive effects of experiment week and treatment on milk production rate, milk remaining in the gland, and milk composition. The effect of treatment on milk production rate was significant, with the average control half-udder producing 0.97 kg/h and the treatment half-udder 0.73 kg/h. The effect of week on milk production rate and the interaction of week × treatment were also significant. The effect of treatment on milk remaining in the gland was significant, illustrating that an increase in milk remaining in the cisternal compartment had been achieved. We detected a significant decrease in milk lactose percentage in treatment half-udders, and a significant increase in somatic cell count (log). The increase was relatively small, from a geometric mean of 26,300 cells/mL in control quarters to 48,300 cells/mL in treatment quarters. The decrease in milk production rate in treatment half-udders supports current knowledge about how mammary epithelial cell secretion, proliferation, and apoptosis are modulated by autocrine-paracrine factors.

A controlled trial was conducted in 5 pasture-grazed commercial dairy herds in Australia in 2012 to determine whether premilking teat disinfection and drying of teats reduces clinical mastitis incidence during early lactation by at least 50%. A 50% reduction was estimated to be the minimum required to justify additional costs of labor, disinfectants, and other resources if premilking teat disinfection was implemented in a 500-cow herd averaging 8 clinical cases per 100 cow-months. A secondary aim was to determine whether this premilking teat disinfection routine reduces incidence of new udder infections. Treatment was applied in each herd for approximately 60 d (range of 59.5 to 61 d), commencing in each herd soon after the start of the herd's main or only calving period. Within each herd, cows were allocated to either the treatment (premilking disinfection) or the control (no premilking disinfection) group based on their herd identity number. During the trial period, any cow having a new case of clinical mastitis or an individual cow cell count greater than 250,000 cells/mL of milk (when preceded by individual cow cell counts of 250,000 cells/mL of milk or below) was deemed to have had a new infection. Overall, neither clinical mastitis incidence nor new infection rate differed significantly between treatment and control groups. Over the whole study period, 98 of the 1,029 cows in the premilking disinfection group and 97 of the 1,025 cows in the control group had clinical mastitis. Total cow-days at risk of clinical mastitis were similar in each group. However, clinical incidence rates were markedly lower in treatment cows in one herd (herd 3; incidence rate ratio=0.34) and there was some evidence that new infection incidence rates were lower in treated cows in this herd (incidence rate ratio=0.42). Rainfall during the study period was below long-term district average in all 5 study herds. Cows' teats were less dirty than in previous, wetter years for the 4 herds where no significant clinical mastitis response was detected but some teat soiling was observed in herd 3 during the study period. Routine application of premilking teat disinfection in pasture-grazed herds is unlikely to produce a worthwhile (economic) reduction in the number of clinical mastitis cases when teats are relatively clean and dry and the clinical mastitis incidence is low. However, premilking disinfection might be worthwhile during periods when teats are heavily soiled and the incidence of clinical mastitis due to environmental pathogens is high.

The objective of this study was to quantify the effect of d-phase (rest phase) duration of pulsation on the teat canal cross-sectional area during the period of peak milk flow from bovine teats. A secondary objective was to test if the effect of d-phase duration on teat canal cross-sectional area was influenced by milking system vacuum level, milking phase (b-phase) duration, and liner overpressure. During the d-phase of the pulsation cycle, liner compression facilitates venous flow and removal of fluids accumulated in teat-end tissues. It was hypothesized that a short-duration d-phase would result in congestion of teat-end tissue and a corresponding reduction in the cross-sectional area of the teat canal. A quarter milking device, designed and built at the Milking Research and Instruction Laboratory at the University of Wisconsin-Madison, was used to implement an experiment to test this hypothesis. Pulsator rate and ratios were adjusted to achieve 7 levels of d-phase duration: 50, 100, 150, 175, 200, 250, and 300ms. These 7 d-phase durations were applied during one milking session and were repeated for 2 vacuum levels (40 and 50kPa), 2 milking phase durations (575 and 775ms), and 2 levels of liner overpressure (9.8 and 18kPa). We observed a significant reduction in the estimated cross-sectional area of the teat canal with d-phase durations of 50 and 100ms when compared with d-phase durations of 150, 175, 225, 250, and 300ms. No significant difference was found in the estimated cross-sectional area of the teat canal for d-phase durations from 150 to 300ms. No significant interaction was observed between the effect of d-phase and b-phase durations, vacuum level, or liner overpressure.