Injections using hypodermic needles cause pain, discomfort, localised trauma and apprehension. Additionally, careful use and disposal of needles is required to avoid transmission of blood-borne pathogens. As an alternative, microneedles can facilitate drug delivery without significantly impacting on pain receptors or blood vessels that reside beneath the skin outer layers. In this study we aim to determine the pain and sensory response to the application of wet-etch silicon microneedles, when used in such a way as to reliably penetrate skin, and provide a preliminary indication of how skin responds to microneedle injury with time. Twelve subjects received single-blinded insertions of a 25-G hypodermic needle and two microneedle arrays (36 needles of 180 and 280 mum height). The optimal method for microneedle application was determined in a pilot study. Pain intensity was scored using a visual analogue scale (VAS) and sensory perception determined using an adapted McGill Pain Questionnaire Short Form. Skin penetration was determined by external staining and measurement of trans-epidermal water loss (TEWL). Mean VAS scores, verbal descriptions and questionnaire responses showed that the 180 and 280 mum microneedles caused significantly less pain and discomforting sensation in participants than the hypodermic needle. Methylene blue staining and TEWL analysis confirmed that microchannels were formed in the skin following microneedle application. Evidence of microchannel repair and resealing was apparent at 8-24 h post-application. In summary, this study shows that pyramidal wet-etch microneedles can penetrate human skin with minimal pain and sensory discomfort, creating transient pathways for potential drug, vaccine and DNA delivery.

This exploratory research study captured the views of the eventual end-users of microneedle technology. Microneedle researchers should now reflect on their research and development activities in the context of stakeholder engagement in order to facilitate the transfer of this new technology 'from bench to bedside.'

No abstract

A design of a microwave noninvasive continuous blood glucose monitoring sensor and its interference test results are presented. The novelty of the proposed sensor is that it comprises two spatially separated split-ring resonators, where one interacts with the change in glucose level of a sample under test while the other ring is used as a reference. The reference ring has a slightly different resonant frequency and is desensitized to the sample owing to its location, thus allowing changes in temperature to be calibrated out. From an oral glucose tolerance test with two additional commercially available sensors (blood strip and continuous glucose monitor) in parallel, we obtained encouraging performance for our sensor comparable with those of the commercial sensors. The effects of endogenous interferents common to all subjects, i.e., common sugars, vitamins (ascorbic acid), and metabolites (uric acid) have also been investigated by using a large Franz cell assembly. From the interference test, it is shown that the change in sensor response is dominated by changes in glucose level for concentrations relevant to blood, and the effects of interferents are negligible in comparison.

Microneedle delivery of nucleic acids, in particular plasmid DNA (pDNA), to the skin represents a potential new approach for the clinical management of genetic skin diseases and cutaneous cancers, and for intracutaneous genetic immunization. In this study excised human skin explants were used to investigate and optimize key parameters that will determine stable and effective microneedle-facilitated pDNA delivery. These include (i) high dose-loading of pDNA onto microneedle surfaces, (ii) stability and functionality of the coated pDNA, (iii) skin penetration capability of pDNA-coated microneedles, and (iv) efficient gene expression in human skin. Optimization of a dip-coating method enabled significant increases in the loading capacity, up to 100 micrograms of pDNA per 5-microneedle array. Coated microneedles were able to reproducibly perforate human skin at low (<1 Newton) insertion forces. The physical stability of the coated pDNA was partially compromised on storage, although this was improved through the addition of saccharide excipients without detriment to the biological functionality of pDNA. The pDNA-coated microneedles facilitated reporter gene expression in viable human skin. The efficiency of gene expression from coated microneedles will depend upon suitable DNA loading, efficient and reproducible skin puncture and rapid in situ dissolution of the plasmid at the site of delivery.