No abstract

The roles in catalysis of several residues in bovine aspartyl (asparaginyl) beta-hydroxylase that are located in a region of homology among alpha-ketoglutarate-dependent dioxygenases were investigated using site-directed mutagenesis. Previous studies have shown that when histidine 675, an invariant residue located in this highly conserved region, was mutated to an alanine residue, no enzymatic activity was detected. A more extensive site-directed mutagenesis study at position 675 has been undertaken to define the catalytic role of this essential residue. The partial hydroxylase activity observed with some amino acid replacements for histidine 675 correlates with the potential to coordinate metals and not with size, charge, or hydrophobic character. Furthermore, the increase in Km for Fe2+ observed with the H675D and H675E mutant enzymes can account for their partial activities relative to wild type. No significant changes in the Km for alpha-ketoglutarate (at saturating Fe2+) or Vmax were observed for these mutants. These results support the conclusion that histidine 675 is specifically involved in Fe2+ coordination. Further site-directed mutagenesis of other highly conserved residues in the vicinity of position 675 demonstrates the importance of this region of homology in catalysis for Asp (Asn) beta-hydroxylase and, by analogy, other alpha-ketoglutarate-dependent dioxygenases.

The stable continuous overproduction of a plasmidencoded protein, beta-lactamase, for at least 50 days by Escherichia coli K-12, RB791(pKN), with release into the culture medium has been demonstrated in two-stage chemostats. The second-stage culture was continuously induced with 0.1 mM IPTG. Continuous expression of beta-lactamase could not be sustained with this strain in a single-stage chemostat because of cell death and selection for lac(-1) cells. Beta-lactamase production in the second stage was sensitive to the second-stage dilution rate and the distribution of the limiting substrate (i.e., glucose) between the first and second stages. The fraction of viable, excreting cells and the average copy number in the induced culture was measurably higher under those conditions of dilution rate and substrate distribution which yielded high beta-lactamase levels. The best operating conditions found at 20 degrees C were a first-stage dilution rate of 0.12 h(-1), a second-stage dilution rate of 0.03 h(-1), and equal glucose feed supplied to each stage. Enzymatically active beta-lactamase was produced at a level of 25% of total cellular protein with 90% excretion yielding 300 mg beta-lactamase/L that was 50% pure at an OD(600) < 6.

We have studied the growth rate dependence of hepatitis B surface antigen (HBsAg) p24s monomer and lipoprotein particle synthesis produced in Saccharomyces cerevisiae using galactose‐limited continuous culture. The hepatitis B virus S gene, which encodes the p24s monomer, is transcribed under the control of the GAL 10p on a chimeric 2‐μm plasmid harbored in a haploid yeast strain. Monomers autonomously form lipoprotein aggregates (particles) in vivo using only host‐cell‐derived components. Steady states were evaluated in a range from 0.015 h−1 to washout (0.143 h−1). Both p24s monomer and HBsAg particle levels, at steady state, varied in an inverse linear manner with growth rate. A consistent excess of total p24s monomer to HBsAg particle, estimated at five‐ to tenfold by mass, was found at all dilution rates. The average copy number of the 2‐μm plasmid (carrying LEU2 selection) remained constant at 200 copies per cell from washout to 0.035 h−1. Surprisingly, the average copy number was undetectable at the lowest dilution rate tested (0.015 h−1), even though HBsAg expression was maximal. Total p24s monomer and HBsAg particle values ranged twofold over this dilution rate range. No differences in the trends for HBsAg expression and average copy number could be detected past the critical dilution rate where aerobic fermentation of galactose and ethanol overflow were observed. HBsAg expression in continuous culture was stable for at least 40 generations at 0.100 h−1. © 1996 John Wiley & Sons, Inc.

A simple mathematical model is developed to help explain the complex population dynamics of an Escherichia coli host-plasmid expression/excretion system for beta-lactamase within single- and two-stage reactors. The model successfully integrates the individual regulatory (tac promoter induction), genetic (runaway plasmid replication), and population dynamics (culture instability) aspects of the system. The model predicts, and experiment confirms, that high-level beta-lactamase production and excretion cannot be easily maintained in single-stage reactors using the current plasmid construction. Stable target protein production and excretion is mathematically predicted, and experimentally confirmed, within two-stage reactors. The model is used to provide insight into engineering a more stable host-vector expression/excretion system for use in single-stage reactors.