We describe the design, fabrication, and performance of a bioreactor that enables both morphogenesis of 3D tissue structures under continuous perfusion and repeated in situ observation by light microscopy. Three-dimensional scaffolds were created by deep reactive ion etching of silicon wafers to create an array of channels (through-holes) with cell-adhesive walls. Scaffolds were combined with a cell-retaining filter and support in a reactor housing designed to deliver a continuous perfusate across the top of the array and through the 3D tissue mass in each channel. Reactor dimensions were constructed so that perfusate flow rates meet estimated values of cellular oxygen demands while providing fluid shear stress at or below a physiological range (<2 dyne cm(2)), as determined by comparison of numerical models of reactor fluid flow patterns to literature values of physiological shear stresses. We studied the behavior of primary rat hepatocytes seeded into the reactors and cultured for up to 2 weeks, and found that cells seeded into the channels rearranged extensively to form tissue like structures and remained viable throughout the culture period. We further observed that preaggregation of the cells into spheroidal structures prior to seeding improved the morphogenesis of tissue structure and maintenance of viability. We also demonstrate repeated in situ imaging of tissue structure and function using two-photon microscopy.

We have previously described the design and operation of a microfabricated bioreactor that supports perfused 3D culture of liver cells and facilitates evolution of tissue-like morphological structures. Here, we describe the functional viability of cells maintained in this microarray bioreactor and examine the influence of different seeding protocols on the evolution of structure and function in comparison with static culture. Primary rat hepatocytes were seeded into the perfusion reactors either as single-cell suspensions immediately after isolation or as spheroidal aggregates formed over a 2- to 3-day period. Initial studies in which cells were cultured for 7 days postisolation revealed significantly greater functional activity and morphological stability of cells that were preaggregated for up to 3 days before seeding in the reactor, compared with direct seeding of single cells. Total albumin secretion and urea genesis rates in single-cell reactor cultures declined significantly during this initial culture period while remaining constant in preaggregated reactor cultures. Longer term studies indicate that rates of albumin secretion and urea genesis are maintained at constant levels through 15 days postisolation. These metabolic rates are an order of magnitude higher than observed for the same preaggregated structures cultured statically with comparable medium ratio and exchange conditions. The metabolic function data are supported by light microscopy images showing viable tissue structures, and electron microscopy images that reveal tight junctions, glycogen storage, and bile canaliculi.

Sinusoidal endothelial cell (SEC) porosities were compared between the periportal (zone 1) and pericentral (zone 3) regions of the rat liver during regeneration following partial hepatectomy (PHx). SEC porosities and fenestration diameters were measured in control livers, as well as at 5 minutes, 24, 48, 72, 96, 120 hours, and 14 days following PHx. Bimodal maximums in both porosity and fenestration diameters were observed in both zones at 5 minutes and 5 days following PHx. SEC porosities increased significantly in both zones 1 and 3 within 5 minutes following PHx, but the increase was maintained only in zone 1 at 24 hours after resection. Following the initial rise, both zones displayed a gradual decrease to less than half their porosity values at 72 hr post-PHx. After 72 hours, porosities increased to over control levels and remained elevated until 14 days after PHx. The decrease in porosity at 72 hr post-PHx is accompanied by ultrastructural changes within the sinusoid at this time. Vascular corrosion casting and transmission electron microscopy (TEM) show sinusoid compression resulting from increased hepatic plate widths due to hepatocyte proliferation in the absence of SEC proliferation. Also at this time, we observed many SEC completely enveloped by stellate cells. The zonal variations observed for porosities throughout regeneration did not correlate with changes in laminin, collagen I and IV, or fibronectin deposition within the space of Disse. Taken together, the data reveal that SEC are dynamic regulators of porosity that respond rapidly and locally to environmental zonal stimuli during liver regeneration. (HEPATOLOGY 2001;33:363-378.)Following chemical or mechanical injury, the liver has the extraordinary capacity to regenerate back to its normal mass within a short time. During regeneration, the same physiologic functions required by the organism must be performed with less metabolic "equipment," and therefore the liver must continuously adapt its metabolic output to its rapidly changing architecture. As a result of tissue loss, the concentrations of many factors, including growth factors, cytokines, and proteases, rise in the blood and liver to promote temporal and spatial proliferation and migration of the various cells to efficiently reconstitute the liver mass (reviewed by Michalopoulos 1 and Fausto 2 ). Following 70% partial hepatectomy (PHx) in the rat, hepatocyte DNA synthesis peaks abruptly at 24 hours after PHx, and essentially terminates DNA synthesis by 72 hours following resection. 3 Sinusoidal endothelial cells (SEC), the open, fenestrated, discontinuous endothelial cells that line the vessels supplying the parenchymal plates, do not initiate DNA synthesis until 48 to 72 hours after resection, peaking at 4 d post-PHx, but continue to proliferate at least until 8 days following PHx. [3][4][5] This cellular order of proliferative events results in the formation of avascular hepatic islands throughout the liver lobule. 6 Subsequent proliferation and migration of the sinusoidal endothelium i...

In Duchenne muscular dystrophy (DMD) patients and the mdx mouse model of DMD, chronic activation of the classical nuclear factor-κB (NF-κB) pathway contributes to the pathogenesis that causes degeneration of muscle fibers, inflammation and fibrosis. Prior studies demonstrate that inhibition of inhibitor of κB kinase (IKK)-mediated NF-κB activation using L-isomer NF-κB essential modulator (NEMO)-binding domain (NBD) peptide-based approaches reduce muscle pathology in the mdx mouse. For our studies, the NBD peptide is synthesized as a fusion peptide with an eight-lysine (8K) protein transduction domain to facilitate intracellular delivery. We hypothesized that the D-isoform peptide could have a greater effect than the naturally occurring L-isoform peptide due to the longer persistence of the D-isoform peptide in vivo. In this study, we compared systemic treatment with low (1 mg/kg) and high (10 mg/kg) doses of L-and D-isomer 8K-wild-type-NBD peptide in mdx mice. Treatment with both L-or D-isoform 8K-wild-type-NBD peptide resulted in decreased activation of NF-κB and improved histology in skeletal muscle of the mdx mouse. However, we observed kidney toxicity (characterized by proteinuria), increased serum creatinine, activation of NF-κB and pathological changes in kidney cortex that were most severe with treatment with the D-isoform of 8K-wild-type-NBD peptide. The observed toxicity was also seen in normal mice.