This study investigated the effects of acute heat stress and slaughter processing on poultry meat quality and carbohydrate metabolism. Broilers (200) were randomly divided into 2 groups receiving heat stress (HS; 36°C for one h), compared to a non-stressed control (C). At slaughter, each group was further divided into 2 groups for slaughter processing (L = laboratory; F = commercial factory). L group breasts were removed immediately after bleeding without carcass scalding or defeathering, and stored at 4°C. F group broilers were scalded (60°C, 45 s) after bleeding and defeathering. Then the breasts were removed and cooled in ice water until the core temperature was ≤4°C. Rates of Pectoralis core temperature and pH decline were changed by slaughter processing, but only HS affected ultimate pH in group L. HS muscles had higher L* values (P < 0.05) than controls at 24 h postmortem. Laboratory processing "hot-deboning" increased drip loss, which resulted in a lower cooked loss (P < 0.05). Postmortem glycolysis was affected only by HS. The speed of lactic acid accumulation and glycogen degradation was faster in the HS group than controls at 5 min postmortem. During storage the glycolysis rates were not different (P > 0.05). Sarcoplasmic protein solubility was higher in F processed birds (P < 0.05). HS decreased the solubility of myofibrillar and total protein in the L-slaughtered birds. Thus, HS caused a higher frequency of accelerated muscle glycolysis than controls. Factory processing (chilling) could not completely eliminate the effects of accelerated glycolysis caused by pre-slaughter HS.

This paper describes the complex effects of postmortem ultimate pH (pHu) on Chinese Yellow crossbreed cattle quality during postmortem ageing and provides an explanation of how pHu affects beef tenderness. High pHu beef had the highest initial tenderness (P < 0.05) compared with other groups at 1 day postmortem. Intermediate and low pHu beef had similar initial WBSF at 1 day postmortem, but intermediate pHu beef had slower tenderization rate than low pHu beef (P < 0.05). Purge loss, cooking loss, L*, a*, and b* values decreased with increasing pHu during ageing (P < 0.05). Myofibril fragmentation index (MFI) was higher in high pHu beef than intermediate and low pHu beef throughout ageing (P < 0.05). Protein degradation studies found that desmin and troponin-T appeared degraded within 0.5 h postmortem for high and low pHu beef, compared to >2 days for intermediate pHu beef. Overall, Chinese Yellow crossbred cattle tenderness is related to pHu, which may be affected by proteolytic enzymatic activity. Therefore, pHu may be used to predict beef tenderness and other quality characteristics during postmortem ageing. To achieve consistent tenderness, different ageing times should be used, depending on pHu.

No abstract

No abstract

No abstract