Yearling and calf finishing trials (replicated over 2 yr) evaluated the feeding value of wet distillers byproducts (wet distillers grains and thin stillage). An additional trial estimated the amount of thin stillage bypassing the rumen when consumed by drinking. Yearlings were 5, 10, and 20% more efficient (linear, P < .01; quadratic, P = .05), whereas calves were 2, 6, and 14% more efficient (linear, P < .01) when fed 5.2, 12.6, and 40.0% (DM basis) wet distillers byproducts, respectively, compared with cattle fed a 79% dry-rolled corn diet. Cattle fed 5.2 or 12.6% wet distillers byproducts, or the dry-rolled corn diet, received similar amounts of protein (crude or metabolizable), which exceeded the metabolizable protein requirement of all cattle. Therefore, differences in efficiency were attributed to differences in energy utilization of the diets. Wet distillers byproducts fed at 5.2, 12.6 and 40.0% contributed 80, 62, and 47% more net energy for gain than corn when fed to yearlings and 17, 33, and 29% more net energy for gain than corn when fed to calves, respectively. Wet distillers byproducts averaged 169% the energy value of corn (2.53 Mcal of NEg/kg) when fed to yearlings and 128% the energy value of corn (1.96 Mcal of NEg/kg) when fed to calves. The increased energy values cannot be explained by increased digestibility, but they may be due to a combination of factors (reduced acidosis, increased energy utilization, yeast end products, etc.) that increase the net energy content of distillers byproducts. Approximately 50% of the thin stillage consumed by drinking bypassed ruminal fermentation.(ABSTRACT TRUNCATED AT 250 WORDS)

Interactions among grain type (grain sorghum, corn or wheat), roughage level and monensin level were studied in four feedlot trials using pen-fed crossbred yearling cattle. In Trial 1, cattle fed high-moisture corn (HMC) were more efficient (.1537 vs .1406 for gain/feed; P less than .01) than cattle fed dry-rolled grain sorghum (DRGS). As level (0, 3, 6, 9%) of dietary roughage was increased, feed efficiency (gain/feed) decreased (.1566, .1461, .1479, .1382; linear, P less than .01). In Trial 2, a grain type (DRGS; dry-rolled corn, DRC; dry-rolled wheat, DRW) x roughage level interaction was observed for daily gain and feed efficiency. Feed efficiency (gain/feed) was decreased when roughage was added to diets containing DRC (.1608 vs .1750) or DRGS (.1674 vs .1465), but not to the diet containing DRW (.1664 vs .1607). In trial 3, a grain type x roughage level x monensin level interaction (P less than .08) was observed for feed efficiency. The addition of 27.5 mg of monensin per kilogram of the 0% roughage-DRC diet tended to improve feed efficiency (.1633 vs .1531), but the addition of monensin to the 7.5% roughage-DRC diet tended to depress feed efficiency (.1476 vs .1575). The addition of either roughage (.1493 vs .1420) or monensin (.1500 vs .1413) to the DRW diet improved feed efficiency. In Trial 4, cattle fed a combination of 75% DRW and 25% DRC were more efficient (.1618 vs .1591; P less than .06) than cattle fed DRC. As level of roughage (0, 3.75, 7.5%) increased, feed efficiency decreased linearly (.1645, .1599, .1569; P less than .0001). Monensin had no effect on feed efficiency. The value of feeding roughage and monensin was variable both across grain types and within similar grain types.

A finishing trial and a metabolism trial were conducted to evaluate sources of supplemental protein in dry-rolled corn (DRC) and dry-rolled grain sorghum (DRGS) diets fed to large-framed calves and to determine effects of grain and protein source on ruminal metabolism. In Exp. 1, 144 Charolais crossbred steer and heifer calves (BW = 269 +/- 3 kg) were used in a randomized complete block design and fed (199 d) DRC or DRGS diets supplemented with urea or urea plus a 60:40 combination (CP basis) of blood meal (BM) and feather meal (FTH). Calves supplemented with urea-BM/FTH were more efficient (P < .05) during the first 41 d of the trial than were calves supplemented with urea alone. After 41 d, daily gain and feed efficiency were not affected (P > .2) by source of protein. The NRC metabolizable protein (MP) requirements accurately predicted response to urea-BM/FTH. In Exp. 2, five ruminally cannulated steers (BW = 721 +/- 20 kg) were used in a 5 x 5 Latin square design and fed (on an ad libitum basis) diets similar to those used in Exp. 1. An additional treatment of DRC supplemented with soybean meal (SBM) was included. Rate (P < .01) and extent of 12-h (P = .14) and 18-h (P < .05) in situ N disappearance of SBM, BM, FTH, DRC, DRGS, and corn silage were greater when diets were supplemented with urea-BM/FTH or SBM. Estimates of escape N (percentage of total N) were 52.3, 93.3, 91.7, 65.7, 63.6, and 23.2% for SBM, BM, FTH, DRC, DRGS, and corn silage, respectively. Finishing calves supplemented with urea were deficient in MP during the early finishing period (0 to 41 d) but were adequate in MP from d 42 to slaughter. Supplementing urea-BM/FTH improved feed efficiency when MP was limiting but not when MP was adequate.

Two finishing trials, one laboratory trial and one metabolism trial were conducted with the following objectives: 1) to determine the associative effects of feeding high-moisture corn (HMC) with either dry-rolled grain sorghum (DRGS) or dry-rolled corn (DRC) and 2) to evaluate HMC when harvested at different moisture levels, stored in different structures, or fed as whole or rolled HMC. In Trial 1, yearling steers (BW, 328 kg) were fed diets containing mixtures of HMC and DRGS. As level (0, 33, 100%, as percentage of grain DM) of DRGS increased, ADG (P less than .03) and gain/feed (P less than .001) decreased linearly; gain/feed tended to be affected quadratically (P = .14). In Trial 2, yearling steers (BW, 382 kg) fed HMC, stored whole in an upright, oxygen-limiting silo and rolled coarsely before feeding, gained faster (1.46 vs 1.36 kg/d) and more efficiently (.142 vs. .131 gain/feed) than steers fed whole HMC (P less than .01). In Trial 3, as length of storage of bunker HMC increased, in vitro rate of starch digestion and soluble N content increased (20.4 and 36.8%, respectively) and grain pH decreased (10.9%). In Trial 4, steers fed HMC or a mixture of 75% HMC with 25% DRGS had similar ruminal pH throughout a grain adaptation period, but total ruminal VFA were greater (P less than .005) for steers fed HMC alone. These data are interpreted to suggest that feeding a mixture of HMC, ground and stored in a bunker or silo bag, with DRGS will result in a 3.2% associative effect. However, no associative effects were measured when a mixture of HMC, stored whole and fed whole or rolled, and DRC were fed.

Four experiments were conducted to evaluate the effect of a soybean hull, soy lecithin, and soapstock mixture on ruminal fiber and protein digestion, growth efficiency of beef calves, and lactational performance of dairy cattle. An initial mixing experiment determined that a 4:1 ratio (DM basis) of soy lecithin:soapstock could be added to soybean hulls at 15% (wt/wt, DM basis); this mixture had acceptable mixing and handling characteristics. Dietary addition of a mixture of 85% soybean hulls, 12% soy lecithin, and 3% soapstock (DM basis; SLS) to provide 0, 3, 5, or 7% supplemental fat resulted in a linear (P < .01) decrease in in situ rate of ruminal NDF digestion with no effect on rate of CP digestion. Daily gain, DMI, and feed efficiency (kilograms of gain/kilogram of DMI) of growing beef calves were not affected (P > .10) as graded levels of SLS replaced corn grain. However, as graded levels of SLS replaced soybean hulls, daily gain and feed efficiency increased linearly (P < .01). Based on the results of these trials, Holstein dairy cattle were fed four isonitrogenous and isoenergetic diets that contained either high levels of nonfiber carbohydrates (43%) and no added fat, 1% ruminally inert fat, a 6% level of SLS, or a 12% SLS level (all on DM basis). Efficiency of 4% fat-corrected milk production (kilograms of milk/kilogram of DMI) was greatest for cows fed SLS at 6% of dietary DM. The SLS mixture was an excellent source of fiber and vegetable fat, comparable in feeding value to corn grain, for inclusion in the diets of beef calves and dairy cows.