Consuming small‐sized fish species whole, and bones of large fish could contribute significantly to reducing the level of micronutrient and protein malnutrition. These fish products are more affordable and could therefore meet the needs of poor, vulnerable groups, particularly in rural and urban areas where limited economic resources prevent dietary diversity. The objectives of the study were to produce fish powder from dried edible byproducts from fish processing factories, an underutilized fish species, burrito and to determine the physical, micromineral, macronutrient and microbiological quality of the dried fish powder. Edible fish processing byproducts and an underutilized fish, burrito (Brachydeuterus auritus) were cleaned thoroughly and dried with a Council for Scientific and Industrial Research‐Food Research Institute (CSIR‐FRI) gas‐fuelled oven at 55°C for 8 h or until dried. The dried products were milled into powder, and packaged into polythene bags. Proximate analysis of the fish powder was done Official Methods of Analysis (AOAC) methods. Minerals and heavy metals in the fish powder were determined by atomic absorption spectrophotometry (AAS). Microbiological quality was determined by Nordic Committee on Food Analysis Method (NMLK) methods. Tuna trimmings contained 80.71 g/100 g protein, whereas burrito contained 70.40 g/100 g protein. Concentrations of cadmium, arsenic, and mercury varied from <1.00 to 1 mg/kg. Lead was found at 0.04 mg/100 g in tuna frames and gills only. All fish byproducts contained high levels of iron, for example, trimmings contained 16.58 mg/100 g, whereas tuna frames and gills also contained 16.82 and 19.54 mg/100 g, respectively. Burrito contained 8.92 mg/100 g. Zinc levels also ranged from 0.41 mg/100 g in tuna trimmings to 1.88 mg/100 g in tuna gills. The powdered samples according to the standards set by Ghana Standard Authority, were acceptable. Consuming small‐ sized fish species whole, and bones of large fish could contribute significantly to reducing the level of micronutrient and protein malnutrition. These are more affordable and could therefore meet the needs of poor, vulnerable groups.

With limited protein resources and depleting commercial fish species there is the need to improve utilization of some of the lesser known species which are underutilized, for example, big eye grunt (burrito), Bachydeuterus auritus, and the flying gurnard (Dactylopterus volitans), (other names Cephalocanthus volitans (local) Pampansre). This study was to characterize some of the proximate and biochemical properties of burrito and the flying gurnard so as to evaluate their potential for use in human nutrition and other value‐added products. Proximate and chemical analysis were determined by the methods of AOAC. Fatty acid profiles were determined following the method of Saaed and Howell (1999). Amino acid profiles for the species were determined according to Bidlingmeyer et al. (1987). The protein content of both the water soluble and salt soluble protein extracts of the fish species were determined by the Bradford Protein Assay method (Bradford 1976). Rancidity of the fish species was assessed by thiobarbituric acid reactive substances (TBARS) and Peroxide value (PV) as described by Saeed and Howell (1999). Burrito contained 18% protein, whereas the flying gurnard contained 22.3%. Calcium content was 296 mg/100 g for burrito and 185 mg/100 g for flying gurnard, whereas iron content was 4.1 mg/100 g and 1.0 mg/100 g for burrito and the flying gurnard, respectively. Palmitic acid (C16) was 27% and 14.3% for the flying gurnard and burrito, respectively. C17: 1ω8 was 3% in the flying gurnard and 0.2% in burrito. Oleic (C18:1ω9) was 17% in the flying gurnard and 6% in burrito. C20:4ω6 was 1.6% in the flying gurnard and 3% in burrito. Docosahexaenoic acid (C22:6ω3) was 4.9% in the flying gurnard and 4.0% in burrito. Both burrito and the flying gurnard are of high nutritional quality as they had a high protein content, good general amino acid profile and abundance of polyunsaturated fatty acids.