A method for the isolation of single plant cells from Taxus suspension cultures has been developed for the analysis of single cells via rapid throughput techniques such as flow cytometry. Several cell wall specific enzymes, such as pectinase, pectolyase Y-23, macerozyme, Driselase(R), and cellulase were tested for efficacy in producing single cell suspensions. The method was optimized for single cell yield, viability, time, and representivity of aggregated cell cultures. The best combination for single cell isolation was found to be 0.5% (w/v) pectolyase Y-23 and 0.04% (w/v) cellulase. High viability (>95%) and high yields of single cell aggregates (>90%) were obtained following 4 hours of digestion for four separate Taxus cell lines. In addition, methyl jasmonate elicitation (200 microM) was found to have no effect on three of the four tested Taxus lines. Isolated single cells were statistically similar to untreated cell cultures for peroxidase activity (model cell wall protein) and paclitaxel content (secondary metabolite produced in Taxus cell cultures). In comparison, protoplasts showed marked changes in both peroxidase activity and paclitaxel content as compared to untreated cultures. The use of flow cytometry was demonstrated with isolated cells that were found to have > 99% viability upon staining with fluorescein diacetate. The development of a method for the isolation of single plant cells will allow the study of population dynamics and culture variability on a single cell level for the development of population models of plant cell cultures and secondary metabolism.

Single cell growth and division was measured via flow cytometry in order to characterize the metabolic variability of Taxus cuspidata suspension cultures, which produce the valuable secondary metabolite Taxol. Good agreement was observed between the cell cycle distribution and biomass accumulation over the batch culture period. Specific growth rates of 0.13 days(-1) by fresh weight and 0.15 days(-1) by dry weight were measured. Elicitation with methyl jasmonate (MJ) significantly decreased both cell cycle progression and biomass accumulation, as the specific growth rate decreased to 0.027 days(-1) by fresh and dry weight. Despite the decrease in biomass accumulation for MJ elicited cultures, sucrose utilization was not significantly different from control cultures. MJ elicitation also increased the accumulation of paclitaxel and other taxanes. The accumulation of upstream taxanes (baccatin III and 10-deactylbaccatin III) increased during exponential growth, reached a maximum around day 12, and then declined throughout the stationary phase. The paclitaxel concentration increased during both exponential growth and stationary phase, reaching a maximum around days 20-25. Throughout the culture period, greater than 70% of the cells were in G(0)/G(1) phase of the cell cycle. Studies using bromodeoxyuridine (BrdU) incorporation showed that approximately 65% of the Taxus cells are noncycling, even during exponential growth. Although the role of these cells is currently unknown, the presence of a large, noncycling subpopulation can have a significant impact on the utilization of plant cell culture technology for the large-scale production of paclitaxel. These results demonstrate that there is a high degree of metabolic heterogeneity in Taxus cuspidata suspension cultures. Understanding this heterogeneity is important for the optimization of plant cell cultures, particularly the reduction of production variability.