This study compared measured gas production (GP) and computed CH4 production values provided by closed or vented bottles connected to gas collection bags. Two forages and 3 concentrates were incubated. Two incubations were conducted, where the 5 feeds were tested in 3 replicates in closed or vented bottles, plus 4 blanks, for a total of 64 bottles. Half of the bottles were not vented, and the others were vented at a fixed pressure (6.8 kPa) and gas was collected into one gas collection bag connected to each bottle. Each bottle (317 mL) was filled with 0.4000 ± 0.0010 g of feed sample and 60 mL of buffered rumen fluid (headspace volume = 257 mL) and incubated at 39.0°C for 24 h. At 24 h, gas samples were collected from the headspace of closed bottles or from headspace and bags of vented bottles and analyzed for CH4 concentration. Volumes of GP at 24 h were corrected for the gas dissolved in the fermentation fluid, according to Henry's law of gas solubility. Methane concentration (mL/100mL of GP) was measured and CH4 production (mL/g of incubated DM) was computed using corrected or uncorrected GP values. Data were analyzed for the effect of venting technique (T), feed (F), interaction between venting technique and feed (T × F), and incubation run as a random factor. Closed bottles provided lower uncorrected GP (-18%) compared with vented bottles, especially for concentrates. Correction for dissolved gas reduced but did not remove differences between techniques, and closed bottles (+25 mL of gas/g of incubated DM) had a greater magnitude of variation than did vented bottles (+1 mL of gas/g of incubated DM). Feeds differed in uncorrected and corrected GP, but the ranking was the same for the 2 techniques. The T × F interaction influenced uncorrected GP values, but this effect disappeared after correction. Closed bottles provided uncorrected CH4 concentrations 23% greater than that of vented bottles. Correction reduced but did not remove this difference. Methane concentration was influenced by feed but not by the T × F interaction. Corrected CH4 production was influenced by feed, but not by venting technique or the T × F interaction. Closed bottles provide good measurements of CH4 production but not of GP. Venting of bottles at low pressure permits a reliable evaluation of total GP and CH4 production.

No abstract

BackgroundIn the last years, difficulties occurring in corn cultivation (i.e., groundwater shortages, mycotoxin contamination) have been forcing dairy farmers to consider alternative silages. Some experiments conducted on lactating cows have proven that the total replacement of corn silage with sorghum silage did not reduce milk yield. However, this kind of substitution involves supplementing sorghum-based diets with grains, to compensate for the lower starch content of sorghum silage compared to corn silage. Change of silage type and inclusion of starch sources in the diet would influence rumen fermentations, with possible effects on milk composition (i.e., fatty acid profile) and coagulation properties. A worsening of milk coagulation properties would have a negative economic impact in Italy, where most of the milk produced is processed into cheese.This study was designed to compare milk composition and quality, with emphasis on fatty acid profile and coagulation properties, in dairy cows fed two diets based on corn or sorghum silage.ResultsThe sorghum diet reduced milk yield (P = 0.043) but not 4% fat corrected milk (P = 0.85). Feeding sorghum silage did not influence milk contents of protein (P = 0.07) and lactose (P = 0.65), and increased fat content (P = 0.024). No differences emerged for milk concentrations of saturated (P = 0.61) and monounsaturated fatty acids (P = 0.50), whereas polyunsaturated fatty acids were lower (P < 0.001) for the sorghum diet. Concentrations of n-6 (P < 0.001) and n-3 fatty acids (P = 0.017) were lower in milk of cows fed the sorghum diet. Milk coagulation properties did not differ between the two diets, except the “a30” (the curd firmness, expressed in mm, 30 min after rennet addition), that was lower (P = 0.042) for the sorghum diet.ConclusionsFeeding a forage sorghum silage, properly supplemented with corn meal, as total replacement of corn silage maintained milk composition and did not influence negatively milk coagulation properties, which have a great economic relevance for the Italian dairy industry. Thus, silages obtained from forage sorghums could have a potential as substitute of corn silages in dairy cow diets.

The in vitro gas production (GP) technique has been widely used for feed evaluation. However, variability in results limits useful comparisons. Results from a ring test undertaken in four laboratories (Italy – IT, Spain – SP, Wales – WA and Denmark – DK) using the same wireless equipment (ANKOM Technology), same substrates and same laboratory protocol are presented, including calculation of repeatability and reproducibility according to ISO 5725-2. Hay, maize starch and straw samples and units without sample (blanks) were incubated in five repetitions using rumen inoculum from cows (DK, IT and WA) or sheep (SP). Curves, corrected for blanks, were fitted using an exponential regression model with a lag time. The following variables were considered: (i) GP24 and GP48: raw values at 24 and 48 h (mL/g DM), corrected for blanks; (ii) A: asymptotic GP (mL/g DM); (iii) T1/2: time when half A is produced (h); (iv) GPMR: maximum predicted GP rate (mL/h); (v) L: lag time (h). A mixed model including laboratories as random effect was used. A significant interaction between substrate and laboratories was found for all variables except A. The most repeatable and reproducible results were observed for A and GP48. The results from this ring test suggest the need for more standardisation, particularly in the procedures that occur outside the laboratory.

The aim of the study was to investigate whether the addition of extruded flaxseed (EF) in dairy cow diets had an effect on milk fat and individual fatty acids (FA) recovery in cheese after 90 d of ripening. Eighteen Holstein-Friesian cows, divided into 3 experimental groups (6 cows/group), were fed 3 isonitrogenous and isoenergetic diets with 0 (CTR), 500 (EF500), or 1,000 g/d (EF1000) of EF in 3 subsequent periods (2 wk/each), following a 3 × 3 Latin square design. Dry matter intake (DMI) and milk yield were recorded daily. Individual milk samples were collected on d 7 and 13 of each period to determine proximate and FA composition. Eighteen cheese-making sessions (2 for each group and period) were carried out, using a representative pooled milk sample obtained from the 6 cows of each group (10L). At 90 d of ripening, cheeses were analyzed for proximate and FA composition. Cheese yield was computed as the ratio between the weights of ripened cheese and processed milk. Recoveries of fat, individual FA, and grouped FA were computed as the ratio between the corresponding weights in cheese and in milk. Inclusion of EF did not affect DMI, milk yield, or milk composition. Compared with CTR, the 2 diets containing EF increased the proportion of C18:3n-3 and total n-3 FA, in both milk and cheese. Cheese yield and cheese fat percentage did not differ among diets. Likewise, milk fat recovery in cheese was comparable in the 3 treatments and averaged 0.85. The recoveries of individual FA were, for the most part, not dissimilar from fat recovery, except for short-chain saturated FA (from 0.38 for C4:0 to 0.80 for C13:0), some long-chain saturated FA (0.56 and 0.62 for C20:0 and C21:0, respectively), and for C18:3n-6 (1.65). The recovery of saturated FA was lower than that of monounsaturated FA, whereas recovery of polyunsaturated FA was intermediate. Compared with medium- and long-chain FA, short-chain FA were recovered to a smaller extent in cheese. No differences in recovery were found between n-6 and n-3 FA. In conclusion, FA have different recoveries during cheese-making, with lower values for the short-chain compared with long-chain FA, and for saturated FA compared with unsaturated FA. The addition of EF in dairy cow diets did not influence cheese yield or fat recovery in cheese, irrespective of the inclusion level. The experiment confirmed that feeding cows with EF represents a successful strategy for improving the FA profile of dairy products, through an increase of n-3 FA.