Growing global population and environmental concerns necessitate the transition from chemical to eco-friendly pest management. Entomopathogenic fungi (EPF) are rising candidates for this task due to their ease of growing, broad host range and unique disease process, allowing EPF to infect hosts directly through its cuticle. However, EPF’s requirement for high humidity negates their integration into conventional agriculture. To mitigate this problem, we formulated Metarhizium brunneum conidia in an oil-in-water Pickering emulsion. Conidia in aqueous and emulsion formulations were sprayed on Ricinus communis leaves, and Spodoptera littoralis larvae were introduced under low or high humidity. The following were examined: conidial dispersion on leaf, larval mortality, conidial acquisition by larvae, effects on larval growth and feeding, and dynamic of disease progression. Emulsion was found to disperse conidia more efficiently and caused two-fold more adhesion of conidia to host cuticle. Mortality from conidia in emulsion was significantly higher than other treatments reaching 86.5% under high humidity. Emulsion was also found to significantly reduce larval growth and feeding, while conferring faster fungal growth in-host. Results suggest that a Pickering emulsion is able to improve physical interactions between the conidia and their surroundings, while weakening the host through a plethora of mechanisms, increasing the chance of an acute infection.

Direct contact between the conidia of entomopathogenic fungi (EPF) and their host is a prerequisite to successful infection; the host can, therefore, be infected by both direct treatment and by transmission of fungal inoculum from infested surfaces. This unique characteristic makes EPF especially relevant for the control of cryptic insects. In the case of the red palm weevil (RPW) Rhynchophorus ferrugineus, the eggs and larvae are almost inaccessible to direct-contact treatment. The objective of the present study was to investigate the mechanism of conidia transmission from a treated surface to host eggs and larvae. Foam pieces infested with Metarhizium brunneum conidial powder, conidial suspension, or distilled water were used as a laying surface for RPW females. The number of eggs laid was not affected by the EPF treatments and ranged from 2 to 14 eggs per female. However, hatching rate and larval survival were significantly reduced in the conidial powder treatment, resulted in 1.5% hatching and no live larvae. In the conidial suspension treatment, 21% of laid eggs hatched, compared to 72% in the control treatment. In both M. brunneum treatments, females’ proboscis, front legs and ovipositor were covered with conidia. The females transferred conidia in both treatments to the laying holes, reaching up to 15 mm in depth. This resulted in reduced egg-hatching rate and significant larval mortality due to fungal infection. The stronger effect on egg and larval survival using dry conidia seemed to result from better conidial adhesion to the female weevil in this formulation. In future studies, this dissemination mechanism will be examined as a prevention strategy in date plantations.

BACKGROUND Intensive application of chemical insecticides is required for aphid pest control. Among the biorational alternatives, entomopathogenic fungi are the most sustainable biocontrol agents; those of the order Hypocreales attack and cause fungal disease in arthropod hosts, with variations in host susceptibility attributed to both fungal and host characteristics. We evaluated inter‐ and intraspecies variations in Metarhizium spp. virulence and differences in fungal disease progression on adult and nymph stages of the green peach aphid, Myzus persicae (Sulzer), a parthenogenetically reproducing insect species. RESULTS Minor interspecies diversity was detected between the generalist Metarhizium species examined. Interestingly, significant intraspecies diversity was observed between Metarhizium brunneum isolates Mb7 and MbK. Infected adult aphids demonstrated similar disease progression for both isolates, mortality rates of more than 80% and fivefold reduction in fecundity. However, nymph mortality was detected only following MbK infection, with 50% mortality and significant reduction in molting rates. Confocal laser scanning microscopy demonstrated the variation in the disease stages of conidial adhesion and hemocoel colonization on each examined day post inoculation for each isolate. Significantly faster disease progression was observed in MbK‐infected versus Mb7‐infected nymphs, the latter demonstrating a higher percentage of uninfected nymphs accompanied with aphid molting. CONCLUSIONS The observed intraspecies variation suggests that altered conidial adhesion to the nymph cuticle is a major factor affecting virulence. We prove the role of nymph ecdysis as a defense mechanism disrupting fungal infection. Because significant differences were observed between closely related isolates, this study emphasizes the importance of appropriate isolate selection for biological control. © 2021 Society of Chemical Industry