Given the hypothesis that microparticles can penetrate the skin barrier along the transfollicular route, this work aimed to obtain and characterise chitosan microparticles loaded with minoxidil sulphate (MXS) and to study their ability to sustain the release of the drug, attempting a further application utilising them in a targeted delivery system for the topical treatment of alopecia. Chitosan microparticles, containing different proportions of MXS/polymer, were prepared by spray drying and were characterised by yield, encapsulation efficiency, size and morphology. Microparticles selected for further studies showed high encapsulation efficiency (∼82%), a mean diameter of 3.0 µm and a spherical morphology without porosities. When suspended in an ethanol/water solution, chitosan microparticles underwent instantaneous swelling, increasing their mean diameter by 90%. Release studies revealed that the chitosan microparticles were able to sustain about three times the release rate of MXS. This feature, combined with suitable size, confers to these microparticles the potential to target and improve topical therapy of alopecia with minoxidil.

Phthalocyanines have been used as systemic photosensitizers because of their high affinity towards tumour tissue, and the high rates of reactive oxygen species produced when they are irradiated during photodynamic therapy. However, the topical administration of these compounds is limited by their large size, poor hydrosolubility and ionic character. This study aimed to investigate the iontophoretic delivery of charged zinc phthalocyanine tetrasulfonic acid (ZnPcS4) from a hydrophilic gel to different skin layers by means of in-vitro and in-vivo studies. Six hours of passive administration was insufficient for ZnPcS4 to cross the stratum corneum (SC) and to reach the epidermis and dermis. No positive effect was reached when anodal iontophoresis was performed, showing that the drug-electrode attraction effect was higher than the electro-osmosis contribution at a pH of 5.5. Cathodal iontophoresis, however, was able to transport significant amounts of the drug to the viable epidermis. In addition, the absence of NaCl in the formulation significantly increased (by five-fold) the amount of ZnPcS4 that crossed the SC and accumulated in the epidermis and dermis. It was possible to visualize the drug accumulation in the follicle openings and in the epidermis, even after SC removal. In-vivo experiments in rat skin showed that these results were maintained in an in-vivo model, even with only 15 min of iontophoresis. In addition, confocal analysis of the treated skin showed a homogeneous distribution of ZnPcS4 in the viable epidermis after this short period of cathodal iontophoresis.

This study examined the potential of iontophoresis in topical photodynamic therapy (PDT) of human invasive squamous cells carcinomas (SCC). SCC was induced in nude BALB/c mice by subcutaneous injection of A431 cells. Tumor penetration and distribution of the photosensitizer tetrasulfonated zinc phthalocyanine (ZnPcS4) was investigated after 10 and 30 min of in vivo iontophoresis of a gel containing ZnPcS4. PDT was performed immediately after iontophoresis using laser at 660 nm with a dose of irradiation of 100 J/cm2 and irradiance of 48 mW/cm2 while tumor growth was measured for 30 days. Iontophoresis increased ZnPcS4 penetration into tumors by 6-fold after 30 min when compared with passive delivery. Confocal microscopy analysis showed that ZnPcS4 was homogeneous distributed within deep regions of the tumor after iontophoresis. Irradiation of the tumors immediately after iontophoresis showed reduction in tumor size by more than 2-fold when compared to non-treated tumors. Iontophoretic-PDT treated tumors presented large areas of necrosis. The study concluded that iontophoretic delivery of photosensitizers could be a valuable strategy for topical PDT of invasive SCC.