Two broiler experiments were conducted to assess the relative bioefficacy of liquid DL-Met hydroxy analog-free acid (MHA-FA) and DL-Met (DLM). Exponential regression analysis was used to determine biological efficacy based on body weight, feed conversion, and carcass responses to dietary Met source. In Trial 1, four graded inclusion levels of DLM and liquid MHA-FA (0.06, 0.12, 0.18, and 0.24%) were each added to a basal diet that met the nutrient and energy requirements of broiler chickens, with the exception of Met + Cys. In four additional treatments, diluted DLM (65%) was added at the same supplementation levels as pure DLM and liquid MHA-FA. In the 42-d trial, broilers responded significantly (P < 0.05) to the supplements. Regression analysis revealed that liquid MHA-FA was 68% (weight gain), 67% (feed conversion), 62% (carcass yield), and 64% (breast meat yield) as efficacious as pure DLM on an as-fed basis. Responses to liquid MHA-FA and diluted DLM were very similar at corresponding supplementation levels. Diluted DLM as an internal standard confirmed that exponential regression analysis was a statistically valid technique for determination of the relative efficacy of nutrient sources. In Trial 2, five graded inclusion levels of each DLM (0.040, 0.091, 0.152, 0.222, and 0.303%) and liquid MHA-FA (0.045, 0.102, 0.170, 0.250, and 0.350%) were added to a basal diet limiting in Met + Cys but adequate in all other nutrients and energy. Liquid MHA-FA was 72% (weight gain), 51% (feed conversion), 48% (carcass yield), and 60% (breast yield) as efficacious as DLM on a weight-for-weight basis.

1. Three experiments were undertaken to determine the optimum inclusion rates of field peas, faba beans, chick peas and sweet lupins in broiler starter and finisher diets in amounts up to 360 g/kg. 2. In experiment A chickens in cages grown to 21 d on diets with field peas and faba beans gave better growth rate and feed efficiency than those with sweet lupins and chick peas. Growth rate and Food conversion ratio (FCR) improved with increasing amounts of faba beans in the diet while for chick peas growth rate and FCR declined. Digesta viscosity and excreta stickiness scores were much higher on diets with sweet lupins. Steam pelleting improved growth rate and FCR on all diets. 3. In experiment B birds were in cages and grown from 21 to 42 d. There were no differences between grain legumes (when combined for all inclusions) for growth rate, food intake or FCR. Viscosity was again much higher on the sweet lupin-based diets while the pancreas was significantly enlarged on the diets with chick peas, as observed previously in chickens grown to 21 d. Steam pelleting of diets gave a consistent and positive response for weight gain and FCR. 4. Experiment C was carried out in pens each holding 60 birds under semi-commercial conditions and grown to 42 d on starter and finisher diets with the same grain legumes as used previously but each at 2 rates of inclusion similar to those in commercial practice. Field peas at 200 to 300 g/kg and chick peas at 150 to 220 g/kg gave inferior growth to faba beans (150 to 180 g/kg) and sweet lupins (120 g/kg). 5. The results of these experiments allowed tentative recommendations to be made to industry for inclusion rates of these cultivars of the 4 grain legumes. These were: field peas 300 g/kg; faba beans 200 g/kg, chick peas 100 g/kg and sweet lupins <100 g/kg. Wet droppings and high gut viscosity were serious problems with sweet lupins although these were not so obvious in experiment C.

1. Experiments were undertaken to determine the chemical composition and apparent metabolisable energy (AME) of field peas, faba beans, sweet lupins and chick peas and the production of hens when each was included in nutritionally similar diets at 250 g/kg in 2 experiments. 2. Amino acid composition, crude protein and AME agreed well with previously published measurements. Detailed analysis of the non-starch polysaccharides (NSPs) showed that sweet lupins were much higher than the other grain legumes in the soluble NSPs and that the NSPs were particularly high in arabinose. The condensed tannin content was highest in field peas followed by faba beans. 3. In the 1st layer experiment over 40 weeks, hen-day egg production was lowest on the faba bean-based diet and egg weight and egg mass were also lowest. Relative viscosity of digesta in the small intestine of hens fed on the sweet lupin-based diet was highest, followed by that of hens fed on field peas. Enlargement of the pancreas was observed in hens consuming chick peas. 4. In experiment 2, in which only sweet lupins and faba beans were used, steam or cold pelleting showed few effects, nor did dehulling of faba beans but egg weight was lower when diets were steam pelleted. Daily food intake was 5.7 g/bird lower on the steam than cold pelleted diets and food conversion ratio tended to be improved (P=0.082). 5. It was concluded that field peas could support good production at 250 g/kg of layer diet. Although chick peas and sweet lupins supported good performance, there was concern about the increased weight of the pancreas and high gut viscosity respectively. Faba beans showed similar hen-d egg production in the 2nd experiment to that of sweet lupins but egg weight tended to be about 0.8 g lower than when on the sweet lupin-based diets.

1. Two broiler experimentss and a layer experiments were conducted on Kunitz trypsin inhibitor (Kti) soybeans (SB) of low trypsin inhibitor (TI) activity to determine their nutritive value when included as mash in least-cost poultry diets. 2. Experiment 1 compared chick performance on the Kti or raw SB using a commercial full-fat SB meal (FFSBM) and a solvent extracted SB meal (SBM) as controls during a 20 d experimental period. Broiler experiment 2 compared Kti and raw SB, non-steamed, or steam-pelleted with and without DL-methionine supplementation added to every treatment containing 170 g SB/kg. For each broiler experiment the levels of each SB were 70, 120 and 170 g/kg with the control birds fed only 170 g SB/kg. 3. The layer experiment, compared steam-pelleted Kti and raw SB against a non-steamed Kti and raw SB each fed at two levels (70 and 110 g/kg) x 30 replicates from 29 weeks of age for 19 weeks in a completely randomised design. Production parameters were measured when diets were formulated to contain minimum required specifications and calculated apparent metabolisable energy (AME). At the completion of each trial, 2 broiler birds from each cage and 5 layer birds per treatment were killed, weighed, and their liver and pancreas weighed. 4. Both broiler experiments indicated that production parameters on the Kti SB treatments were significantly lower (P<0.05) than on the two commercial control SB treatments. However, the Kti treatments were superior to the raw SB treatments. 5. Pancreas weight increased with increasing inclusion of both raw and Kti SB, suggesting that a TI was causing the depression in performance. The AME of the Kti SB was similar to that of commercial FFSB meal. After steam conditioning, the raw SB meal AME value of 9.5 MJ/kg dry matter (DM) was improved to 14.1 MJ/kg DM by reduced TI activity, but this AME improvement with TI activity reduction, plus the supplementation with DL-methionine on birds fed the raw SB had no effect (P>0.05) on any parameter evaluated in experiment 2. 6. The layer experiment showed that hens on the Kti SB treatments had significantly greater live weight gain (LWG), egg weight and daily egg mass than birds given raw SB. A reduced food intake (FI) was observed in the Kti treatments but egg mass was generally similar to that on the FFSB control diet, indicating that Kti SB supported excellent egg production at an inclusion of 110 g/kg. The depressed performance observed for broiler chicks suggest that younger birds are more susceptible to the effects of SB TI.

The influence of bacterial and fungal enzyme supplements at 0.1 5 and 0.30% of barley based diets on the growth and nutrient utilization of female broiler chickens (Tegel strain) was studied in three experiments. All diets were based on Australian barley cultivars and were fed as mash. Body weight gain was improved by 12 to 25% and food consumption increased by 3 to 21% in supplemented treatments at 4 weeks of age. Diets based on the cultivars Clipper, Ketch and Noyep each grown at Coonalpyn, Port Pirie and Ardrossan in South Australia gave similar growth responses to enzyme supplementation. The metabolizable energy content of the diets was improved by 0.75 MJ kg-1 and 1.53 MJ kg-1 dry matter. An examination of the utilization of dietary nitrogen, soluble sugar, starch, pentosans and soluble �-glucan could not account for the improved metabolizable energy.