The colloidal properties of the casein micelles play a major role in the structural properties of milk protein concentrates. Because of their great technological importance, the structural-functional relationships of casein micelles have been studied for decades in skim milk; however, novel ingredients are now available with higher protein concentrations and varying in composition. The colloidal behavior of caseins in these systems is not fully understood. Concentrates prepared with membrane technologies, and subjected to pre-or postmodifications that affect their technological functionality, have become increasingly widespread. This has created large opportunities for innovation and generation of value-added ingredients. The manner in which caseins interact with themselves and the other components in these concentrates will affect the structure of the final matrix. During concentration by filtration, the interparticle distance between the micelles decreases considerably, increasing their spatial correlation and decreasing their diffusivity. Rearrangements occur due to changes in environmental conditions, such as ionic composition, osmotic stress, shear, pH, or heating temperature. This will have important consequences on bulk viscosity of the concentrates, as well as on the mode of formation of structures' building blocks. This paper aims at highlighting some of the important factors affecting the colloidal structure of casein micelles, their destabilization and network formation, namely, processing history, volume fraction, composition of the serum phase, and ionic equilibrium. Understanding these factors will lead to a better quality control of dairy ingredients and to the development of a new generation of ingredients with targeted functionality.

No abstract

No abstract

Concentrating milk is a common unit operation in the dairy industry. With the reduction of water, the particles interact more frequently with each other and the functionality of the casein micelles may depend on the interactions occurring during concentration. The objective of this research was to investigate the effect of concentration on the renneting properties of the casein micelles by comparing 2 concentration methods: ultrafiltration and osmotic stressing. Both methods selectively concentrate the protein fraction of milk, while the composition of the soluble phase is unaltered. To evaluate possible differences in the rearrangements of the casein micelles during concentration, renneting properties were evaluated with or without the addition of soluble caseins, added either before or after concentration. The results indicate that casein micelles undergo rearrangements during concentration and that shear during membrane filtration may play a role in affecting the final properties of the milk.

This research focused on understanding physical and chemical changes occurring to concentrated milk protein suspensions as a function of time. Skim milk (untreated and heat treated at 90°C for 10 min) was concentrated at 6 times the original volume using osmotic stressing, a noninvasive concentration method, maintaining the serum composition as close as possible to that of native milk. A protease inhibitor cocktail, with broad specificity for the inhibition of serine, cysteine, aspartic proteases, and aminopeptidases, was added in selected samples. Within 9 d of storage at 4°C, the apparent viscosity increased markedly for both unheated and heated concentrated milk, but not for those in the presence of protease inhibitors. However, only unheated milk showed a significant increase in the apparent diameter of the casein micelles. Matrixassisted laser desorption-ionization time-of-flight mass spectrometry measurements indicated a significantly lower extent of proteolysis in heated than in unheated samples. The microstructure of the aggregates was observed using field emission scanning electron microscopy, and unheated samples clearly showed aggregation of casein micelles with storage time. In heated samples, aggregation was instead triggered by heat-induced protein-protein interactions.