Background: Establishing the bioequivalence of topical drug products is a costly and time-consuming process since, with few exceptions, clinical efficacy trials are required. Objective: To develop a surrogate for clinical bioequivalence testing through evaluation of the kinetics of drug absorption in vitro through excised human skin. Methods: The percutaneous absorption of seven approved generic topical drug products was compared with their corresponding reference products during preclinical development using the Franz diffusion cell. Thereafter, following the conduct of bioequivalence trials and regulatory approval of these products in the United States, clinical data became available to which the in vitro data were compared. Results: In six of the seven cases the in vitro test:reference ratio for total absorption was close to one and indicated that the products were equivalent, in agreement with the clinical data. Results from the seventh case, in which the test:reference ratio was only 0.63, indicated that the in vitro model actually had greater sensitivity than the clinical method to detect small differences between products. Conclusion: These data demonstrate the relevance and predictive power of the in vitro human skin model and strongly support its use as a surrogate for in vivo bioequivalence studies.

BackgroundThe availability of generic topical dermatological drug products is constrained by the limited methods established to assess topical bioequivalence (BE). A novel cutaneous pharmacokinetic approach, dermal open-flow microperfusion (dOFM), can continuously assess the rate and extent to which a topical drug becomes available in the dermis, to compare in vivo dermal bioavailability (BA) and support BE evaluations for topical products.ObjectiveTo evaluate whether dOFM is an accurate, sensitive, and reproducible in vivo method to characterize the intradermal BA of acyclovir from 5 % acyclovir creams, comparing a reference (R) product either to itself or to a different test (T) product.MethodsIn a single-center clinical study, R or T products were applied to six randomized treatment sites on the skin of 20 healthy human subjects. Two dOFM probes were inserted in each treatment site to monitor the intradermal acyclovir concentration for 36 h. Comparative BA (of R vs. R and T vs. R) was evaluated based on conventional BE criteria for pharmacokinetic endpoints (area under the curve and maximum plasma concentration) where the 90 % confidence interval of the geometric mean ratio between the T and R falls within 0.80–1.25.ResultsThe positive control products (R vs. R) were accurately and reproducibly confirmed to be bioequivalent, while the negative control products (T vs. R) were sensitively discriminated not to be bioequivalent.ConclusionsdOFM accurately, sensitively, and reproducibly characterized the dermal BA in a manner that can support BE evaluations for topical acyclovir 5 % creams in a study with n = 40 (20 subjects in this study).

Immunostimulatory oligodeoxynucleotides (ODN) containing cytosine-guanine (CpG) motifs are powerful stimulators of innate as well as adaptive immune responses, exerting their activity through triggering of the Toll-like receptor 9. We have previously shown that encapsulation in liposomal nanoparticles (LN) enhances the immunostimulatory activity of CpG ODN (LN-CpG ODN) (Mui et al. in J Pharmacol Exp Ther 298:1185, 2001). In this work we investigate the effect of encapsulation on the immunopotency of subcutaneously (s.c.) administered CpG ODN with regard to activation of innate immune cells as well as its ability to act as a vaccine adjuvant with tumor-associated antigens (TAAs) to induce antigen (Ag)-specific, adaptive responses and anti-tumor activity in murine models. It is shown that encapsulation specifically targets CpG ODN for uptake by immune cells. This may provide the basis, at least in part, for the significantly enhanced immunostimulatory activity of LN-CpG ODN, inducing potent innate (as judged by immune cell activation and plasma cytokine/chemokine levels) and adaptive, Ag-specific (as judged by MHC tetramer positive T lymphocytes, IFN-gamma secretion and cytotoxicity) immune responses. Finally, in efficacy studies, it is shown that liposomal encapsulation enhances the ability of CpG ODN to adjuvanate adaptive immune responses against co-administered TAAs after s.c. immunization, inducing effective anti-tumor activity against both model and syngeneic tumor Ags in murine tumor models of thymoma and melanoma.

Aims: To examine the existing literature to determine the degree to which percutaneous absorption data obtained using the excised human skin model match those obtained from living man. Methods: The scientific literature was reviewed to collect data on compounds whose percutaneous absorption through human skin had been measured under both in vitro and in vivo conditions. The in vitro-in vivo (IVIV) correlation was evaluated by computing the in vitro/in vivo ratio using total absorption (percent of applied dose) as the metric for comparison. Results: A total of 92 data sets were collected from 30 published studies. The average IVIV ratio across all values was 1.6, though for any single data set there could be a nearly 20-fold difference between the in vitro and in vivo values. In 85% of the cases, however, the difference was less than 3-fold. The correlation was significantly improved when data were excluded from studies in which the protocols for both studies were not fully harmonized. For harmonized data sets the average IVIV ratio was 0.96 and there was a less than 2-fold difference between the in vitro and in vivo results for any one compound, with IVIV ratios ranging from 0.58 to 1.28. The dominant factors leading to exclusion of data were the use of skin from different anatomical sites and vehicles of differing composition. Conclusions: Percutaneous absorption data obtained from the excised human skin model closely approximate those obtained from living man when the two study protocols are appropriately matched.

Introduction Exposure to heat can impact the clinical efficacy and/or safety of transdermal and topical drug products. Understanding these heat effects and designing meaningful in vitro and in vivo methods to study them are of significant value to the development and evaluation of drug products dosed to the skin. Areas covered This review provides an overview of the underlying mechanisms and the observed effects of heat on the skin and on transdermal/topical drug delivery, thermoregulation and heat tolerability. The designs of several in vitro and in vivo heat effect studies and their results are reviewed. Expert opinion There is substantial evidence that elevated temperature can increase transdermal/topical drug delivery. However, in vitro and in vivo methods reported in the literature to study heat effects of transdermal/topical drug products have utilized inconsistent study conditions, and in vitro models require better characterization. Appropriate study designs and controls remain to be identified, and further research is warranted to evaluate in vitro-in vivo correlations and the ability of in vitro models to predict in vivo effects. The physicochemical and pharmacological properties of the drug(s) and the drug product, as well as dermal clearance and heat gradients may require careful consideration.