The influence of three precooking methods (steaming, oven-baking and microwave-cooking) on the chemical composition and lipid quality of silver carp fillets was evaluated. The changes in protein, fat and moisture were found to be significant for all the treatments (P £ 0.05). The iron content in the samples subjected to steam-cooking increased; however, the other precooking methods did not change the mineral contents (P ‡ 0.05). The free fatty acid content of the fillets did not change by the different precooking methods, while thiobarbituric acid (TBA) values increased for oven-and microwave-cooked fillets and remained constant in the steam-cooked samples. Conjugated diene and browning colour formation levels significantly increased in the oven-baked fillets. Oven-baking and microwave-cooking marginally affected the fatty acid composition of the silver carp. On comparing the raw and precooked fillets, steam-cooking was found to be the best precooking method on retaining nutritional constituents.

Summary In this study, the flux decline mechanisms were identified during membrane clarification of red plum juice at several processing parameters, including pore size, membrane type, transmembrane pressure, temperature and velocity. The results were used to investigate the effect of changes in operating conditions on the intensity of membrane fouling. Also, scanning electron microscopy (SEM) was used for analysing fouling‐layer morphology. These results showed that the main mechanism responsible for membrane fouling was cake formation (over 95% fitness) occurring in the first stage of the process. Intermediate, standard and complete blockings were formed during most of the runs as filtration proceeded. The results also indicated that increasing the temperature from 30 to 40 °C was the most effective factor in decreasing cake‐layer fouling, reducing it by about 66.7%. Furthermore, an increase in processing velocity of up to 0.5 m s−1 had the greatest effect on intermediate blocking, reducing it by about 86.1%. Also, increasing pressure up to 2.9 bar completely eliminated standard blocking and complete blocking. Finally, microstructure analysis of membrane using SEM confirmed that cake formation had the greatest impact on membrane fouling.

Summary The influence of four different filling media (sunflower oil, soybean oil, olive oil and brine) on the oxidation and lipid quality of canned silver carp was evaluated. Hydrolytic rancidity showed that free fatty acid contents in brine and soybean oil canned muscle were higher than olive oil or sunflower oil canned samples. Conjugated diene (CD) levels in soybean oil canned samples increased but the highest CD values were found in canned silver carp using brine as filling medium. Except for olive oil canned muscle, significant increase in thiobarbituric acid (TBA) values was obtained. The highest TBA value was observed in soybean oil canned sample. Canning led to exchange of fatty acids between the fat in the silver carp muscle and the filling media used. Results indicate that the fat composition of canned silver carp tends to be similar to that of the fat used as filling media.

The effect of kefiran on cold-set gelation of whey protein isolate (WPI) at 25 °C was studied using rheological measurements and environmental scanning electron microscopy (ESEM). The gelation of samples was induced by the addition of glucono-δ-lactone to the dispersions. WPI concentration was maintained at 8% (w/v) and the concentration of kefiran varied from 0 to 0.08% (w/v). According to rheological measurements, the addition of kefiran into WPI dispersions resulted in a significant increase in the gel strength, the yield stress, and the shear stress values at the flowing point. The gelling point and gelation pH of samples decreased significantly with an increase in kefiran concentration. ESEM micrographs showed that the presence of kefiran played an important role in the microstructure formation of gels. The microstructure of kefiran-WPI mixed gels was more compact and dense, compared to the WPI gel. Depletion interactions between kefiran and whey protein aggregates can be regarded as the chief factor which was responsible for these effects. The present work demonstrated that rheological and microstructural properties of acid-induced whey protein gels were improved by the addition of kefiran.