Wheat noodles were prepared using flour to which hydroxypropylated tapioca starch was added, and the effect of this addition on the moisture distribution within the noodles during cooking was examined using a digital image processing technique. The addition of the modified starch slightly increased the moisture content and narrowed the flat distribution near the noodle surface. The distribution features reflected the changes in the water absorption behaviour caused by the properties of the modified starch and the reduction in the gluten content. Addition of the modified starch lowered Young's modulus and the energy for 99% strain of the noodles in the texture analysis to, at maximum 35% and 65%, and decreased the breakability of the noodles. These changes in the moisture distribution and textural properties have been ascribed to changes in both the state of the starch granules near the surface and the structure of the gluten network.

Wheat starch dispersions of 10-40% (w/w) were gelatinized and the change in turbidity of each solution during storage was measured in the 400-1100 nm wavelength range. The relative transmittance, defined as the ratio of transmittance at any storage time to that at the initial time, decreased when the solutions were stored at 5 and 30 °C; the decrease, reflecting the progress of retrogradation, was larger at 5 °C than at 30 °C. Most of the changes in relative transmission taking place over 14 days were achieved during the first 90 min. The change in the relative transmittance is inversely proportional to the energy required for deformation. The kinetics on change in relative transmittance can be expressed by Weibull equation. The larger rate constant at higher starch concentration could be ascribed to the state of the starch granules, which depended on starch concentration.

Wheat noodles cooked for different periods of time were stored at 5 °C, and color changes in their cross sections were quantitatively assessed by digital image analysis. The color of noodles with flattened moisture distributions whitened greatly during the early stages of chilled storage due to the retrogradation of starch, with the color change showing a significant correlation with the changes in noodle fragility. Color changes were also measured for wheat noodles and noodles containing modified starch with internal moisture distributions, and local changes within the noodles were kinetically analyzed. The addition of modified starch significantly reduced the color change in the noodle interior, where the moisture content was relatively low. Scanning calorimetric measurements indicated differences in the gelatinized state of modified starch and original wheat starch at low moisture contents, which affected the rate of color change in the interior of noodles containing modified starch.

No abstract