A combined extraction‐HPLC procedure was developed on a microscale to determine the amounts of the different gluten protein types (ω5‐, ω1,2‐, α‐ and γ‐gliadins; high molecular weight [HMW] and low molecular weight [LMW] glutenin subunits) in wheat flour. After preextraction of albumins and globulins from flour (100 mg) with a salt solution (2 × 1.0 mL), extraction of gliadins was achieved with 60% aqueous ethanol (3 × 0.5 mL). Subsequently, the glutenin subunits were extracted under nitrogen and at 60°C with 50% aqueous 1‐propanol containing Tris‐HCl (0.05 mol/L, pH 7.5), urea (2 mol/L) and dithioerythritol (1%). The separation and quantitative determination of gliadins and glutenin subunits was then performed by reversed‐phase HPLC on C8 silica gel at 50°C using a gradient of increasing acetonitrile concentration in the presence of 0.1% trifluoroacetic acid. The flow rate was 1.0 mL/min, and the detection wavelength was 210 nm. Temperature and flow rate were modified for the quantitation of single underivatized HMW subunits. To determine the absolute amounts of protein types, different protein standards (gliadin, LMW and HMW subunits, bovine serum albumin) with known protein contents were compared to HPLC absorbance areas. The calibration curves were almost identical and linear over a broad range (20–220 μg). This extraction‐HPLC procedure allows an accurate, reproducible, sensitive, and relatively fast quantitative determination of all gluten protein types in wheat flour, and can be applied to quality evaluation of cereals as raw materials or in processed products.

High molecular weight (HMW) or low molecular weight (LMW) subunits of different chemical state (reduced, reoxidized with KBrO3, or KIO3) or gliadins were added in 1% amounts to a base flour of the wheat cultivar Rektor and mixed with water. The corresponding doughs were then characterized by microscale extension tests and by microbaking tests and were compared to doughs from the base flour without additives. The maximum resistance of dough was strongly increased by HMW subunits in a reduced state and by HMW subunits reoxidized with KBrO3. A moderate increase of resistance was caused by HMW subunits reoxidized with KIO3 and by LMW subunits reoxidized with KBrO3 or KIO3. This resistance was strongly lowered by LMW subunits in a reduced state and by gliadins. The extensibility of dough was significantly increased only by gliadins and reduced HMW subunits; HMW subunits reoxidized with KBrO3 had no effect, and all other fractions had a decreasing effect. In particular, glutenin subunits reoxidized with KIO3 induced marked decrease of extensibility, resulting in bell‐shaped curve extensigrams, which are typical for plastic properties. The effect of reoxidized mixtures (2:1) of HMW and LMW subunits on maximum resistance depended on the oxidizing agent and on the conditions (reoxidation separated or together); extensibility was generally decreased. Bread volume was increased by addition of HMW subunits (reduced or reoxidized with KBrO3) and decreased by LMW subunits (reoxidized with KBrO3 or KIO3) and by a HMW‐LMW subunit mixture (reoxidized with KBrO3). The volume was strongly decreased by addition of reduced LMW subunits. A high bread volume was related to higher values for both resistance and extensibility.

No abstract

Rheological and breadmaking properties of untreated and suboptimally stored wheat samples (grain moisture: 20%, temperature: 20°C) and also of wheat which was inoculated withFusarium spp. were investigated. The deoxynivalenol (DON) content of the stored and inoculated wheat samples ranged between 820-12,000 μg/kg. Gluten proteins were isolated with different extraction solutions and the fractions obtained were analysed by means of RP-HPLC. Microextension tests and micro-baking tests were used for the determination of dough properties (maximum resistance (MR) and extensibility (EX)) and bread volume, respectively. In spite of the extremely high DON concentrations of some wheat samples contaminated withFusarium spp. they showed only a slight decrease of the amount of gluten proteins. Extension tests of dough led to a slight decrease of MR, bread volumes stayed almost the same compared with the non-contaminated grain. The contamination of wheat withAspergillus andPenicillium led to a high decrease of gluten proteins, which resulted in an extremely decreased MR of the dough and a very low bread volume.

No abstract