Refractory ceramic fibers (RCF) are man-made vitreous fibers used primarily in industrial high-temperature applications, especially for insulation of furnaces and kilns. Because of their increasing use and potential for human exposure, a chronic toxicity/carcinogenicity inhalation study was conducted in Fischer 344 (F344) rats. Five groups of 140 weanling male F344 rats were exposed via noseonly inhalation to either HEPA-filtered air (chamber controls) or 30 mg/m(3) (approximately 220 fibers/cm(3)) of three types [kaolin-based, high-purity, and aluminum zirconia silica (AZS)] of "size-selected" RCF fibers (approximately 1µ in diameter and approximately 20 um in length) and an "after-service" heat-treated (2400°F for 24 h) kaolin-based fiber for 6 h/day, 5 days/wk for 24 mo. They were then held unexposed until approximately 20% survival and then sacrificed at 30 mo. A positive control group of 80 F344 rats was exposed to 10 mg/m(3) chrysotile asbestos. Croups of 3-6 animals were sacrificed at 3, 6, 9, 12, 15, 18, and 24 mo to follow the progression of lesions and to determine fiber lung burdens. Additional groups of 3 rats were removed from exposure at 3, 6, 9, 12, and 18 mo and were held until sacrificed at 24 mo (recovery groups) for similar determinations. Lung burdens increased rapidly for all RCFs, appearing to plateau by about 12 mo. By 24 mo, lung burdens ranged from 2.6 to 9.6 × 10(5) fiberslmg of dry lung tissue for the RCFs tested. Treatment-related lesions were restricted to the lungs. To some extent all types of RCF resulted in macrophage infiltration, bronchiolization of proximal alveoli, and microgranuloma formation by 3 mo of exposure. Interstitial fibrosis was observed at 6 mo for all types of RCF, except the "after-service" fiber where fibrosis was not seen until 12 mo. The lesions progressed in severity until 12-15 mo, after which they plateaued. A minimal amount of focal pleural fibrosis was first observed at 9 mo and progressed to a mild severity by the end of the study. Fxposure-related pulmonary neoplasms (bronchoalveolar adenomas and carcinomas combined) were observed with all 4 types of RCF [kaolin, 16 of 123 (13%); AZS, 9 of 121 (7.4%); high-purity, 19 of 121 (15.7%); and "after-service,"4 of 118 (3.4%)], compared to 2 of 120 (1.5%) in the untreated air controls. Pleural mesotheliomas were observed in two kaolin, three AZS, two high-purity, and one "after-service" exposed rats. A comparable but slightly greater amount of fibrosis was observed in the lungs of the positive (chrysotile asbestos) controls. The incidence of bronchoalveolar neoplasms in the chrysotile exposed rats was 13 of 69 (18.8%), and a mesothelioma occurred in 1 (1.4%) animal. The results of this study showed that the four types of RCF studied had carcinogenic activity in rats at the maximum tolerated dose.

No abstract

Fiberglass (FG) is the largest category of man-made mineral fibers (MMVFs). Many types of FG are manufactured for specific uses building insulation, air handling, filtration, and sound absorption. In the United States, > 95% of FG produced is for building insulation. Several inhalation studies in rodents of FG building insulation have shown no indication of pulmonary fibrosis or carcinogenic activity. However, because of increasing use and potential for widespread human exposure, a chronic toxicity/carcinogenicity inhalation study of a typical building insulation FG (MMVF 10a) was conducted in hamsters, which were shown to be highly sensitive to the induction of mesotheliomas with another MMVF. A special-application FG (MMVF 33) and amosite asbestos were used for comparative purposes. Groups of 140 weanling male Syrian golden hamsters were exposed via nose-only inhalation for 6 h/day, 5 days/wk for 78 wk to either filtered air (chamber controls) or MMVF 10a, MMVF 33, or amosite asbestos at 250-300 WHO fibers/cm(3) with two additional amosite asbestos groups at 25 and 125 WHO fibers/cm(3). They were then held unexposed for 6 wk until approximately 10-20% survival. After 13, 26, 52, and 78 wk, various pulmonary parameters and lung fiber burdens were evaluated. Groups hamsters were removed from exposure at 13 and 52 wk and were held until 78 wk (recovery groups). Initial lung deposition of long fibers (>20 microm in length) after a single 6-h exposure was similar for all 3 fibers exposed to 250-300 fibers/cm(3). MMVF 10a lungs showed inflammation (which regressed in recovery hamsters) but no pulmonary or pleural fibrosis or neoplasms. MMVF 33 induced more severe inflammation and mild interstitial and pleural fibrosis by 26 wk that progressed in severity until 52 wk, after which it plateaued. While the inflammatory lesions regressed in the recovery animals, pulmonary or pleural fibrosis did not. A single multicentric mesothelioma was observed at 32 wk. No neoplasms were found in the remainder of the study. Amosite asbestos produced dose-related inflammation and pulmonary and pleural fibrosis as early as 13 wk in all 3 exposure levels. The lesions progressed during the course of the study, and at 78 wk severe pulmonary fibrosis with large areas of consolidation was observed in the highest 2 exposure groups. Progressive pleural fibrosis with mesothelial hypertrophy and hyperplasia was present in the thoracic wall and diaphragm in most animals and increased with time in the recovery hamsters. While no pulmonary neoplasms were observed in the amosite exposed hamsters, a large number of mesotheliomas were found; 25 fibers/cm(3), 3.6%; 125 fibers/cm(3), 25.9%; and 250 fibers/cm(3), 19.5%. For the 3 fiber types, the severity of the lung and pleural lesions generally paralleled the cumulative fiber burden, especially those >20 microm length, in the lung, thoracic wall, and diaphragm. They also inversely paralleled the in vitro dissolution rates; that is, the faster the dissolution, the lower were the cumulative lung burdens ...

No abstract

Refractory ceramic fibers (RCF) are man-made vitreous fibers used primarily in industrial high-temperature applications, especially for insulation of furnaces and kilns. Because of their increasing use and potential for human exposure an in an effort to define the dose-response, as a follow up to a maximum tolerated dose [30 mg/m(3)] study in rats (Mast et al., 1995), a multiple dose chronic toxicity/carcinogenicity inhalation study was conducted in Fischer 344 (F344) rats. Four groups of 140 weanling male F344 rats were exposed via noseonly inhalation to either HEPA-filtered air (chamber controls) or 3, 9, or 16 mg/m(3)(approximately 36, 91, and 162 fibers/cm(3)) of kaolin-based "size-selected" RCF fibers (approximately 1 µm in diameter and approximately 20 µm in length) for 6 h/day, 5 days/wk for 24 mo. They were then held unexposed until approximately 20% survival and sacrificed (30 mo). Croups of 3-6 animals were sacrificed at 3, 6, 12, 18, and 24 mo to follow the progression of pulmonary lesions and to determine fiber lung burdens. Additional groups of 3-6 rats were removed from exposure at 3, 6, 12, and 18 mo and were held until sacrificed at 24 mo (recovery groups) for similar determinations. A dose-related increase in fiber lung burden was observed. Lung burdens at 24 mo ranged from 5.6 × 10(4) to 27.8 × 10(4) fibers/mg dry lung tissue. Significant increases in lung weights and lung to body weight ratios were seen in the high-dose group. Treatment-related lesions were restricted to the lungs. To some extent, all doses of RCF resulted in minimal to mild macrophage infiltration, bronchiolization of proximal alveoli, and microgranuloma formation by 12 mo of exposure. Interstitial fibrosis was observed at 12 mo in the 9 and 16 mg/m(3) groups but not in the low-dose group at any time point. A minimal amount of focal pleural fibrosis was first observed at 12 mo in the 9 and 76 mg/m(3) dose groups and progressed to a mild severity in the high-dose group by the end of the study. The incidence of pulmonary neoplasm's was well within the range typically reported in the male F344 rat. Neoplasm's (bronchoalveolar adenomas and carcinomas) were observed in all groups 10 mg/m(3) (air control), 1 of 129 (0.8%); 3 mg/m(3), 2 of 123 (1.6%); 9 mg/m(3), 5 of 127 (3.9%); 16 mg/m(3), 2 of 124 (1.6%)]. A single pleural mesothelioma was observed in an animal exposed to 9 mg/m(3) of kaolin RCF. The results of this study suggest that the dose response for primary lung neoplasms is steep, while that for mesothelioma may not be.