Yarrowia lipolytica is a biotechnological chassis for the production of a range of products, such as microbial oils and organic acids. However, it is unable to consume xylose, the major pentose in lignocellulosic hydrolysates, which are considered a preferred carbon source for bioprocesses due to their low cost, wide abundance and high sugar content. Here, we engineered Y. lipolytica to metabolize xylose to produce lipids or citric acid. The overexpression of xylose reductase and xylitol dehydrogenase from Scheffersomyces stipitis were necessary but not sufficient to permit growth. The additional overexpression of the endogenous xylulokinase enabled identical growth as the wild type strain in glucose. This mutant was able to produce up to 80g/L of citric acid from xylose. Transferring these modifications to a lipid-overproducing strain boosted the production of lipids from xylose. This is the first step towards a consolidated bioprocess to produce chemicals and fuels from lignocellulosic materials.

BackgroundThe yeast Saccharomyces cerevisiae plays an essential role in the fermentation of lignocellulosic hydrolysates. Weak organic acids in lignocellulosic hydrolysate can hamper the use of this renewable resource for fuel and chemical production. Plasma-membrane remodeling has recently been found to be involved in acquiring tolerance to organic acids, but the mechanisms responsible remain largely unknown. Therefore, it is essential to understand the underlying mechanisms of acid tolerance of S. cerevisiae for developing robust industrial strains.ResultsWe have performed a comparative analysis of lipids and fatty acids in S. cerevisiae grown in the presence of four different weak acids. The general response of the yeast to acid stress was found to be the accumulation of triacylglycerols and the degradation of steryl esters. In addition, a decrease in phosphatidic acid, phosphatidylcholine, phosphatidylserine and phosphatidylethanolamine, and an increase in phosphatidylinositol were observed. Loss of cardiolipin in the mitochondria membrane may be responsible for the dysfunction of mitochondria and the dramatic decrease in the rate of respiration of S. cerevisiae under acid stress. Interestingly, the accumulation of ergosterol was found to be a protective mechanism of yeast exposed to organic acids, and the ERG1 gene in ergosterol biosynthesis played a key in ergosterol-mediated acid tolerance, as perturbing the expression of this gene caused rapid loss of viability. Interestingly, overexpressing OLE1 resulted in the increased levels of oleic acid (18:1n-9) and an increase in the unsaturation index of fatty acids in the plasma membrane, resulting in higher tolerance to acetic, formic and levulinic acid, while this change was found to be detrimental to cells exposed to lipophilic cinnamic acid.ConclusionsComparison of lipid profiles revealed different remodeling of lipids, FAs and the unsaturation index of the FAs in the cell membrane in response of S. cerevisiae to acetic, formic, levulinic and cinnamic acid, depending on the properties of the acid. In future work, it will be necessary to combine lipidome and transcriptome analysis to gain a better understanding of the underlying regulation network and interactions between central carbon metabolism (e.g., glycolysis, TCA cycle) and lipid biosynthesis.Electronic supplementary materialThe online version of this article (10.1186/s13068-018-1295-5) contains supplementary material, which is available to authorized users.