Barley is a problematic raw material for ethanol processing due to its chemical composition. ?-glucans and pentosans high content increases the mass viscosity and digestible carbohydrates loss at еру water-heat treatment stage. The enzymes used to pre-treat grain prior to fermentation are traditionally ?-amylases and glucoamylases. The purpose of the work is to determine the optimal ratio of enzymes introduced in different periods of water-heat treatment. The object of study was barley: starch 52, protein 11.5, hemicellulose 5.1, ?-glucan 3.9, moisture 14.0. Enzyme preparations Alphaferm 3500L (0.5–1.0 AC / g starch), ViscoStar 150L (3700 units KS / cm3; 140 units ? – GcS / cm3; 1900 units CMC / cm3.), Prolive BS Liquid (600-750 units PS / cm?) were used in the work. The dynamics of viscosity change in the process of water-heat treatment was investigated in the work as well. It was found out that the dosage of the enzyme preparation Alphaferm 3500L has the greatest effect on the mass fraction of dry substances in the filtrate of barley mix, while the dosage of other enzyme preparations and the duration of the experiment have a smaller and similar effect. It was proved that the application of a multienzyme complex reduces the viscosity by 82% compared to the control. The method of indefinite Lagrange multipliers was used to determine the optimal mode of water-heat treatment. It was found out that the maximum accumulation of dry substances in the mixture is 16.4% and is achieved after 2.5 hours with the following doses of enzyme preparations: Alphaferm 3500 L - 0.6 units. AC / g starch; ViscoStar 150L - 0.025 units GCS / g starch; Prolyve BS Liquide 0.25 units PS / g starch.

Effect of technological parameters the process of ethanol production in the saccharification of barley. Vestnik voronezhskogo gosudar-stvennogo universiteta inzhenernyh tekhnologij [Proceedings of the Voronezh state university of engineering technologies]. 2016, no. 1, pp. 211-214. (In Russ.

Saccharomyces cerevisiae yeast is used in the production of ethyl alcohol. The main requirements for yeast used in the production of ethyl alcohol from starch-containing raw materials: alcohol yeast used in the processing of starchy raw materials must have high fermentation activity; complete fermentability of sugars, resistance to metabolic products, resistance to the development of extraneous microflora. Proteolytic enzyme preparation Prolive BS Liquid was used as a source of protease. Kingphos enzyme preparation was used as a source of phytase. The effect of the enzyme preparations of the neutral protease Prolive BS Liquid and Phytase Kingphos on the fermentation activity of alcohol yeast Saccharomyces cerevisiae race XII was studied. The maximum fermentation activity is possessed by yeast cultivated on the wort, obtained using protease and phytase. The duration of the exponential growth phase in the experiment is 14–16 hours, in the control -18–20 hours. The exponential phase is described by the Mono equation. Compared to the yeast in the control, the yeast in the experiment multiplies more intensively, and by 14–16 hours of growth, about 170 million yeast cells accumulate in the culture medium, and the yeast in the control-about 95 million yeast cells by 18–20 h of growth. The specific growth rate was maximum in the logarithmic phase and amounted to 0.35 million cells / cm3 • h in the experimental samples and 0.25 million cells / cm3 • h in the control. It was found that the maximum accumulation of yeast cells was observed when the neutral enzyme Prolive BS Liquid was added to the wort with a dosage of 0.2 units. PS/g of starch and enzyme preparation Phytase Kingfos with a dosage of 0.5 units. FS/g of starch, the yeast cell content in mature yeast reached 170 million cells / cm3 by 16-18 hours of cultivation, the yeast has a high fermentation activity.

В монографии рассматриваются актуальные вопросы, стоящие перед современными исследователями, предлагаются оригинальные решения ряда научно-методических и технологических вопросов. Издание может быть полезно научным работникам, специалистампрактикам, преподавателям всех уровней образования, интересующимся проблемами развития современной науки и технологий.Авторы публикуемых материалов несут ответственность за содержание своих работ, точность цитат, легитимность использования иллюстраций, приведенных цифр, фактов, названий, персональных данных и иной информации, а также за соблюдение законодательства Российской Федерации и сам факт публикации.Полные тексты всех глав в открытом доступе размещены в Научной электронной библиотеке Elibrary.ru в соответствии с Договором № 467-03/2018K от 19.03.2018 г.УДК 001.12 ББК 70