Biogas Production and Fundamental Mass Transfer Mechanism in Anaerobic Granular Sludge

Abstract

Anaerobic granules are responsible for organic degradation and biogas production in a reactor. The biogas production is entirely dependent on a mass transfer mechanism, but so far, the fundamental understanding remains poor due to the covered surface of the reactor. The study aimed at investigating the fundamental mass transfer characteristics of single anaerobic granules of different sizes using microscopic imaging and analytical monitoring under single and different organic loadings. The experiment was conducted in a micro reactor and mass transfer was calculated using modified Fick’s law. Scanning electron microscopy was applied to observe biogas production zones in the granule, and a lab-scale microscope equipped with a camera revealed the biogas bubble detachment process in the micro reactor for the first time. In this experiment, the granule size was 1.32, 1.47, and 1.75 mm, but 1.75 mm granules were chosen for further investigation due to their large size. The results revealed that biogas production rates for 1.75 mm granules at initial Chemical Oxygen Demand (COD) 586, 1700, and 6700 mg/L were 0.0108, 0.0236, and 0.1007 m3/kg COD, respectively; whereas the mass transfer rates were calculated as 1.83 × 10−12, 5.30 × 10−12, and 2.08 × 10−11 mg/s. It was concluded that higher organic loading and large granules enhance the mass transfer inside the reactor. Thus, large granules should be preferred in the granule-based reactor to enhance biogas production.

Modeling factors of biogas technology adoption: a roadmap towards environmental sustainability and green revolution

“…However, this depends on adoption awareness (Mohsin et al 2022 ; Pilloni et al 2020 ). Biogas production from biological leftover has recognized as a renewable energy cause (Afridi et al 2019 ). There are several productive biogas plants in South Asian nations, including India, Bangladesh, China, and Nepal (Wang et al 2020b ).…”

Evaluating Barriers on Biogas Technology Adoption in China: The Moderating Role of Awareness and Technology Understanding

“…The adoption of biogas technology provides health advantages and financial benefits with the lowest cost at 13.7%, but it depends on the awareness level of adopters Pilloni et al, 2020). Biogas generation through organic waste has been acknowledged as a sustainable energy source (Afridi et al, 2019). On the contrary, biogas plants are successful, running with a higher number in South Asian countries such as China, Bangladesh, India, and Nepal (Wang Z et al, 2020).…”

Situation Analysis and the Potential for Circularity of the Wastewater Sector in Lithuania

“…There is both a need and an opportunity to move further away from "end-of-pipe" solutions to prevention and circularity. Various authors note that wastewater treatment plants (WWTPs) should be, and are increasingly being, designed not only to perform their traditional function of treating wastewater to a quality that can be safely discharged into the natural environment but also to become bioenergy plants (biogas production) or even biorefineries [3][4][5][6][7].…”