Melon seed oil utilization for biodiesel production and analysis of liquid–liquid equilibrium for the system biodiesel + methanol + glycerin

Abstract

In the present study, seeds from yellow melon (Cucumis melo l.), considered an industrial and domestic waste, were used as an oleaginous source to produce biodiesel by transesterification reaction in methanol and due to the importance and the lack of data, a study of phase equilibrium of the system biodiesel + methanol + glycerin was also conducted. The mean molecular mass the theoretical mass of biodiesel, and the conversion rate of the reaction were calculated. For the liquid–liquid study, Othmer‐Tobias and Hand correlations were applied to evaluate the data reliability of the tie‐lines and the NRTL and UNIQUAC models were used to predict the phase equilibrium. The results showed that oil from melon seeds could be a new alternative for the production of biodiesel, with a conversion rate close to 85%. The equilibrium data showed that the biodiesel obtained from melon seeds oil presented advantage in the production process, since the biodiesel is easily separated from the methanol and glycerol in the separation step, avoiding additional costs with steps of purification. Among the models evaluated, better agreement in the results was observed when NRTL was used (s.d. = 1.25%), followed by UNIQUAC model (s.d. 2.70%). © 2016 American Institute of Chemical Engineers Environ Prog, 36: 325–332, 2017

Experimental Data and Phase Equilibrium Modeling in Ternary and Pseudoquaternary Systems of Sunflower Oil for Biodiesel Production

“…These data were used to estimate binary interaction parameters of the UNIQUAC model, and the results show good agreement between the experimental data and calculated values. Sena and Pereira studied the liquid–liquid equilibrium of biodiesel from melon seed oil–methanol–glycerol. The authors used the NRTL and UNIQUAC models to analyze the phase equilibrium.…”

Antioxidative potential of Phyllanthus emblica for oxidation stability of biodiesels

“…This results in the formation of two phases; the upper phase was methyl esters (biodiesels) and the lower part was glycerin. Biodiesels were then washed with the warm water four to five times to remove the traces of glycerin, unreacted catalyst and soap formed during the transesterification .…”

Modeling and global optimization of biodiesel synthesis using hybrid response surface methodology‐crow search algorithm: Case study of papaya seed waste oil utilization

“…There are more than 350 oil‐containing seeds considered as potential feedstocks for biofuels. Some of them are palm, jatropha, coconut, sunflower, soybean, rapeseed, and castor oil 6–8 . However, most of these bio‐oil seeds are also important feedstocks for the human food chain 9,10 .…”