While photosynthetic microalgae, such as Chlorella, serve as feedstocks for nutritional oils and biofuels, heterotrophic cultivation can augment growth rates, support high cell densities, and increase triacylglycerol (TAG) lipid content. However, these species differ significantly in their photoautotrophic and heterotrophic characteristics. In this study, the phylogeny of thirty Chlorella strains was determined in order to inform bioprospecting efforts and detailed physiological assessment of three species. The growth kinetics and lipid biochemistry of C. protothecoides UTEX 411, C. vulgaris UTEX 265, and C. sorokiniana UTEX 1230 were quantified during photoautotrophy in Bold's basal medium (BBM) and heterotrophy in BBM supplemented with glucose (10 g L−1). Heterotrophic growth rates of UTEX 411, 265, and 1230 were found to be 1.5-, 3.7-, and 5-fold higher than their respective autotrophic rates. With a rapid nine-hour heterotrophic doubling time, Chlorella sorokiniana UTEX 1230 maximally accumulated 39% total lipids by dry weight during heterotrophy compared to 18% autotrophically. Furthermore, the discrete fatty acid composition of each strain was examined in order to elucidate lipid accumulation patterns under the two trophic conditions. In both modes of growth, UTEX 411 and 265 produced 18∶1 as the principal fatty acid while UTEX 1230 exhibited a 2.5-fold enrichment in 18∶2 relative to 18∶1. Although the total lipid content was highest in UTEX 411 during heterotrophy, UTEX 1230 demonstrated a two-fold increase in its heterotrophic TAG fraction at a rate of 28.9 mg L−1 d−1 to reach 22% of the biomass, corresponding to as much as 90% of its total lipids. Interestingly, UTEX 1230 growth was restricted during mixotrophy and its TAG production rate was suppressed to 18.2 mg L−1 d−1. This constraint on carbon flow raises intriguing questions about the impact of sugar and light on the metabolic regulation of microalgal lipid biosynthesis.

Chlorella sorokiniana CS-01, UTEX 1230 and UTEX 2714 were maintained in 10% anaerobic digester effluent (ADE) from cattle manure digestion and compared with algal cultivation in Bold's Basal Medium (BBM). Biomass of CS-01 and UTEX 1230 in ADE produced similar or greater than 280mg/L after 21days in BBM, however, UTEX 2714 growth in ADE was suppressed by more than 50% demonstrating a significant species bias to synthetic compared to organic waste-based media. The highest accumulation of protein and starch was exhibited in UTEX 1230 in ADE yielding 34% and 23% ash free dry weight (AFDW), respectively, though fatty acid methyl ester total lipid measured less than 12% AFDW. Results suggest that biomass from UTEX 1230 in ADE may serve as a candidate alga and growth system combination sustainable for animal feed production considering high yields of protein, starch and low lipid accumulation.

Triacylglycerol (TAG) analysis and quantification are commonly performed by first obtaining a purified TAG fraction from a total neutral lipid extract using thin-layer chromatography (TLC), and then analyzing the fatty acid composition of the purified TAG fraction by gas chromatography (GC). This process is time-consuming, labor intensive and is not suitable for analysis of small sample sizes or large numbers. A rapid and efficient method for monitoring oil accumulation in algae using high performance liquid chromatography for separation of all lipid classes combined with detection by evaporative light scattering (HPLC–ELSD) was developed and compared to the conventional TLC/GC method. TAG accumulation in two Chlamydomonas reinhardtii (21 gr and CC503) and three Chlorella strains (UTEX 1230, CS01 and UTEX 2229) grown under conditions of nitrogen depletion was measured. The TAG levels were found to be 3–6 % DW (Chlamydomonas strains) and 7–12 % DW (Chlorella strains) respectively by both HPLC–ELSD and TLC/GC methods. HPLC–ELSD resolved the major lipid classes such as carotenoids, TAG, diacylglycerol (DAG), free fatty acids, phospholipids, and galactolipids in a 15-min run. Quantitation of TAG content was based on comparison to calibration curves of trihexadecanoin (16:0 TAG) and trioctadecadienoin (18:2 TAG) and showed linearity from 0.2 to 10 μg. Algal TAG levels >0.5 μg/g DW were detectable by this method. Furthermore TAG content in Chlorella kessleri UTEX 2229 could be detected. TAG as well as DAG and TAG content were estimated at 1.6 % DW by HPLC–ELSD, while it was undetectable by TLC/GC method.

Cell-free extracts of Lactobacillus casei 393 required two enzyme systems for production of acetoin and diacetyl from pyruvate. An enzyme closely associated with the particulate fraction obtained after sonic oscillation produced α-acetolactate, required thiamine pyrophosphate and magnesium for optimal activity, and was inhibited by citrate. Acetolactate was converted to diacetyl and acetoin by both enzymatic and nonenzymatic processes. The enzyme responsible for conversion of acetolactate to diacetyl and acetoin was readily solubilized by sonication of cells. This enzyme required thiamine pyrophosphate or pyridoxalamine for optimal activity and its activity was enhanced in cells cultured in media containing citrate. Results obtained suggested that under conditions which exist in cultures, α-acetolactate was decarboxylated to diacetyl primarily by a nonenzymatic process.

Chlorella species from the UTEX collection, classified by rDNA-based phylogenetic analysis, were screened based on biomass and lipid production in different scales and modes of culture. The lead candidate strains of C. sorokiniana UTEX 1230 and C. vulgaris UTEX 395 and 259 were compared between conditions of vigorous aeration with filtered atmospheric air and 3% CO2 shake-flask cultivation. The biomass of UTEX 1230 produced 2 times higher at 652 mg L(-1) dry weight under both ambient CO2 vigorous aeration and 3% CO2 conditions, while UTEX 395 and 259 under 3% CO2 increased to 3 times higher at 863 mg L(-1) dry weight than ambient CO2 vigorous aeration. The triacylglycerol contents of UTEX 395 and 259 increased more than 30 times to 30% dry weight with 3% CO2, indicating that additional CO2 is essential for both biomass and lipid accumulation in UTEX 395 and 259.