Alphonso mango slices in syrup were frozen under thirteen different conditions, stored for three months at -28°C and the quality of the products assessed chemically, microbiologically and organoletically. The quality was insensitive to the freezing rate (cryogenic freezing, blast freezing or domestic deep freezing) and to the addition of 0.1% vitamin C to the cover syrup. Presoaking in CaCI, prior to pasteurization caused a marked firming of the slices. Soaking the slices in acidic syrup followed by mild pasteurization greatly decreased the microbial counts but had an adverse effect on flavour. Fruit frozen in 40" Brix syrup had a better flavour than that frozen in 20" Brix syrup. Acceptable slices with good nutrient retention were produced by freezing in 40" Brix syrup using a domestic deep freezer.

Summary The investigation had as its principal objects, determination of the microbiological effectiveness of the chlorination of polluted water supplies used for buttermaking, the influence of high chlorine dosages on butter flavour and an examination of the reproducibility of butter grading by subjective methods. A preliminary trial in which pasteurized sweet cream was made into butter using polluted as well as chlorinated water, revealed that there were marked differences in the condition and quality of the finished product. Butter washed with contaminated water developed rancidity within twenty‐one days at 37 to 41 °F. whereas water from the same source, but which contained 5 p. p.m. residual chlorine, resulted in butter which retained a pleasing flavour and aroma for six weeks. In the main experiment, six duplicate lots of unsalted butter were made from ripened cream, using treated and untreated water from the same source, with identical buttermaking methods. The untreated water contained large numbers of psychrophilic bacteria, including Pseudomonas putrefaciens. These organisms grew actively in unsalted butter held at 45 to 50°F. Chlorination of the water with varying dosages of from 10 to 200 p. p.m. available chlorine, sixteen hours before use, resulted in practically a complete destruction of the spoilage organisms. The cream used during the main experiment was ripened at 40 to 50°F. for two days after pasteurizing by the H. T.S. T. method before churning. On microbiological examination, the butter produced from this cream was found to contain large numbers of spoilage organisms, and became rancid within four weeks when stored at 45 to 50°F. However, the microbiological results indicate the superior quality of those butters made with chlorinated water. A consensus of the grading results obtained, substantiates the anticipated superior quality of butter made using chlorinated water, compared with that made with an impure supply. No chlorine taint was detected in the butter, although water containing as much as 100 to 200 p. p.m. residual chlorine had been used in preparing two of the samples. The arbitrary nature of subjective grading is reflected in the differing conclusions arrived at by individual members of the graders' panel.

No abstract