Shale formations play fundamental roles in large-scale geologic carbon sequestration (GCS) aimed primarily to mitigate climate change and in smaller-scale GCS targeted mainly for CO2-enhanced gas recovery operations. Reactive components of shales include expandable clays, such as montmorillonites and mixed-layer illite/smectite clays. In this study, in situ X-ray diffraction (XRD) and in situ infrared (IR) spectroscopy were used to investigate the swelling/shrinkage and H2O/CO2 sorption of Na(+)-exchanged montmorillonite, Na-SWy-2, as the clay is exposed to variably hydrated supercritical CO2 (scCO2) at 50 °C and 90 bar. Measured d001 values increased in stepwise fashion and sorbed H2O concentrations increased continuously with increasing percent H2O saturation in scCO2, closely following previously reported values measured in air at ambient pressure over a range of relative humidities. IR spectra show H2O and CO2 intercalation, and variations in peak shapes and positions suggest multiple sorbed types of H2O and CO2 with distinct chemical environments. Based on the absorbance of the asymmetric CO stretching band of the CO2 associated with the Na-SWy-2, the sorbed CO2 concentration increases dramatically at sorbed H2O concentrations from 0 to 4 mmol/g. Sorbed CO2 then sharply decreases as sorbed H2O increases from 4 to 10 mmol/g. With even higher sorbed H2O concentrations as saturation of H2O in scCO2 was approached, the concentration of sorbed CO2 decreased asymptotically. Two models, one involving space filling and the other a heterogeneous distribution of integral hydration states, are discussed as possible mechanisms for H2O and CO2 intercalations in montmorillonite. The swelling/shrinkage of montmorillonite could affect solid volume, porosity, and permeability of shales. Consequently, the results may aid predictions of shale caprock integrity in large-scale GCS as well as methane transmissivity in enhanced gas recovery operations.

Expandable clays such as montmorillonite have interlayer exchange sites whose hydration state can be systematically varied from near anhydrous to almost bulk-like water conditions. This phenomenon has new significance with the simultaneous implementation of geological sequestration and secondary utilization of CO 2 to both mitigate climate warming and enhance extraction of methane from hydrated clay-rich formations. In this study, the partitioning of CO 2 a n d H 2 O between Na-, Ca-, and Mg-exchanged montmorillonite and variably hydrated supercritical CO 2 (scCO 2 ) was investigated using in situ X-ray diffraction (HXRD), infrared (IR) spectroscopic titrations, and quartz crystal microbalance (QCM) measurements. Density functional theory calculations provided mechanistic insights. Structural volumetric changes were correlated to quantified changes in sorbed H 2 O and CO 2 concentrations as a function of percent H 2 O saturation in scCO 2 . Intercalation of CO 2 is inhibited when the clay is fully collapsed (dehydrated interlayer), peaks sharply with the introduction of some H 2 O and partial expansion of the interlayer region, and then decreases systematically with further hydration of the clay. This behavior is discussed in the context of recent theoretical calculations of the montmorillonite H 2 O-CO 2 system.

The interaction of anhydrous supercritical CO(2) (scCO(2)) with both kaolinite and ~1W (i.e., close to but less than one layer of hydration) calcium-saturated montmorillonite was investigated under conditions relevant to geologic carbon sequestration (50 °C and 90 bar). The CO(2) molecular environment was probed in situ using a combination of three novel high-pressure techniques: X-ray diffraction, magic angle spinning nuclear magnetic resonance spectroscopy, and attenuated total reflection infrared spectroscopy. We report the first direct evidence that the expansion of montmorillonite under scCO(2) conditions is due to CO(2) migration into the interlayer. Intercalated CO(2) molecules are rotationally constrained and do not appear to react with waters to form bicarbonate or carbonic acid. In contrast, CO(2) does not intercalate into kaolinite. The findings show that predicting the seal integrity of caprock will have complex dependence on clay mineralogy and hydration state.

Carbonation reactions are central to the prospect of CO(2) trapping by mineralization in geologic reservoirs. In contrast to the relevant aqueous-mediated reactions, little is known about the propensity for carbonation in the key partner fluid: supercritical carbon dioxide containing dissolved water ("wet" scCO(2)). We employed in situ mid-infrared spectroscopy to follow the reaction of a model silicate mineral (forsterite, Mg(2)SiO(4)) for 24 h with wet scCO(2) at 50 °C and 180 atm. The results show a dramatic dependence of reactivity on water concentration and the presence of liquid water on the forsterite particles. Exposure to neat scCO(2) showed no detectable carbonation reaction. At 47% and 81% water saturation, an Ångstrom-thick liquid-like water film was detected on the forsterite particles and less than 1% of the forsterite transformed. Most of the reaction occurred within the first 3 h of exposure to the fluid. In experiments at 95% saturation and with an excess of water (36% above water saturation), a nanometer-thick water film was detected, and the carbonation reaction proceeded continuously with approximately 2% and 10% conversion, respectively. Our collective results suggest constitutive links between water concentration, water film formation, reaction rate and extent, and reaction products in wet scCO(2).

Continued global use of fossil fuels places a premium on developing technology solutions to minimize increases in atmospheric CO 2 levels. CO 2 storage in reactive basalts might be one of these solutions by permanently converting injected gaseous CO 2 into solid carbonates. Herein, we report results from a field demonstration in which ∼1000 metric tons of CO 2 was injected into a natural basalt formation in eastern Washington state. Following post-injection monitoring for 2 years, cores were obtained from within the injection zone and subjected to detailed physical and chemical analysis. Nodules found in vesicles throughout the cores were identified as the carbonate mineral, ankerite Ca[Fe,Mg,Mn](CO 3 ) 2 . Carbon isotope analysis showed the nodules are chemically distinct compared with natural carbonates present in the basalt and in clear correlation with the isotopic signature of the injected CO 2 . These findings provide field validation of rapid mineralization rates observed from years of laboratory testing with basalts.