Substrate specific cellular responses are the result of a complex biological system that includes protein adsorption, receptor-ligand binding, and signal transduction. This investigation attempted to identify specific proteins adsorbed from human serum that may be responsible for the previously reported in vitro surface dependent behavior of human macrophages and foreign body giant cells (FBGCs). The adsorption of human albumin, ␣ 2 -macroglobulin, complement factor 3b, fibronectin, IgG, thrombospondin, vitronectin (VN), and von Willebrand factor (vWF) from a 25% serum solution was quantified with 125 I-labeled protein. Adsorption substrates included clean glass, alkyl-silane modified glass, amino-silane modified glass, poly(ethylene oxide) (PEO)-coupled glass, and the reference biomaterials poly(etherurethane urea), Silastic, and poly(tetrafluoroethylene) (PTFE). Following quantification of 2-h adsorption, surfaces were treated with sodium dodecyl sulfate (SDS) and the level of adsorbed proteins remaining was quantified. The pre-and post-SDS adsorption were both compared to previously reported surface dependent in vitro macrophage and FBGC behavior on the same surfaces; however, no correlations could be made. Adsorption strength, defined as the percentage of initially adsorbed protein that remained adsorbed after SDS treatment, correlated well with previously reported in vitro cellular behavior indicating that adsorbed vWF, IgG, and VN may be involved in the modulation of adherent macrophage and FBGC behavior. Those surfaces that strongly adsorbed vWF also inhibited longterm macrophage adhesion, while those surfaces that strongly adsorbed IgG promoted long-term macrophage adhesion. In addition, the highest levels of FBGC formation had been observed only on those surfaces that strongly adsorbed VN. Subsequent human monocyte cultures on protein preadsorbed substrates confirmed the inhibitory effect of adsorbed vWF and the promoting effect of IgG on longterm macrophage adhesion as predicted by adsorption strength correlations. However, preadsorbed VN was not observed to modulate FBGC formation, which is in contrast to the conclusions of the adsorption correlations.

Substrate specific cellular responses are the result of a complex biological system that includes protein adsorption, receptor-ligand binding, and signal transduction. This investigation attempted to identify specific proteins adsorbed from human serum that may be responsible for the previously reported in vitro surface dependent behavior of human macrophages and foreign body giant cells (FBGCs). The adsorption of human albumin, alpha(2)-macroglobulin, complement factor 3b, fibronectin, IgG, thrombospondin, vitronectin (VN), and von Willebrand factor (vWF) from a 25% serum solution was quantified with (125)I-labeled protein. Adsorption substrates included clean glass, alkyl-silane modified glass, amino-silane modified glass, poly(ethylene oxide) (PEO)-coupled glass, and the reference biomaterials poly(etherurethane urea), Silastic(R), and poly(tetrafluoroethylene) (PTFE). Following quantification of 2-h adsorption, surfaces were treated with sodium dodecyl sulfate (SDS) and the level of adsorbed proteins remaining was quantified. The pre- and post-SDS adsorption were both compared to previously reported surface dependent in vitro macrophage and FBGC behavior on the same surfaces; however, no correlations could be made. Adsorption strength, defined as the percentage of initially adsorbed protein that remained adsorbed after SDS treatment, correlated well with previously reported in vitro cellular behavior indicating that adsorbed vWF, IgG, and VN may be involved in the modulation of adherent macrophage and FBGC behavior. Those surfaces that strongly adsorbed vWF also inhibited long-term macrophage adhesion, while those surfaces that strongly adsorbed IgG promoted long-term macrophage adhesion. In addition, the highest levels of FBGC formation had been observed only on those surfaces that strongly adsorbed VN. Subsequent human monocyte cultures on protein preadsorbed substrates confirmed the inhibitory effect of adsorbed vWF and the promoting effect of IgG on longterm macrophage adhesion as predicted by adsorption strength correlations. However, preadsorbed VN was not observed to modulate FBGC formation, which is in contrast to the conclusions of the adsorption correlations.

Surface immobilized polyethylene oxide (PEO) has been shown to efficiently reduce protein adsorption and cellular adhesion, resulting in a biologically passive surface. To explore the in vitro effects of surface immobilized PEO on the human inflammatory cells, macrophages, and foreign body giant cells (FBGCs), we developed a diisocyanate-based method for coupling PEO to amine-modified glass, a surface previously shown to enhance macrophage adhesion and FBGC formation. Contact angle analysis and X-ray photoelectron spectroscopy confirmed the presence of PEO molecules bound to the surface and revealed that PEO molecular weight significantly influenced the efficiency of PEO coupling. We used a 10-day human monocyte culture protocol to demonstrate that the presence of surface coupled PEO molecules does not significantly decrease initial monocyte density or monocyte-derived macrophage density after 3 days. However, PEO-coupled surfaces significantly reduced long-term monocyte-derived macrophage density and virtually eliminated interleukin-4-induced FBGC formation observed at day 10. The cellular response to these PEO-coupled surfaces was related to the molecular weight of the PEO chains, which was varied between 200 Da and 18.5 kDa. These results suggest that an optimized PEO surface treatment may be effective in reducing inflammatory cell adhesion and possible degradation during the inflammatory response to an implanted biomedical device.

A cytokine-based, in vitro model of foreign body giant cell (FBGC) formation was utilized to examine the effect of biomaterial surface chemistry on the adhesion, motility, and fusion of monocytes and macrophages. Human monocytes were cultured for 10 days on 14 different silane-modified glass surfaces, during which time the cells assumed the macrophage phenotype. The adhesion of monocytes and macrophages during the culture period decreased by an average of approximately 50%, with the majority of cell loss observed during days 1-3. Most important, the adhesion of monocytes and macrophages was surface independent except for two surfaces containing terminal methyl groups, which decreased adhesion levels. Interleukin-4 (IL-4) and granulocyte-macrophage colony-stimulating factor (GM-CSF) were added to the medium to induce FBGC formation and enhance macrophage adhesion, respectively. Surprisingly, GM-CSF decreased long-term monocyte/macrophage adhesion. IL-4-induced FBGC density was strongly influenced by the surface carbon content, as determined by X-ray photoelectron spectroscopy (XPS). In contrast, contact angle and surface energy displayed no correlation with FBGC formation. The motility of adherent macrophages, as measured by time-lapse confocal microscopy, was not affected significantly by differences in surface chemistry or the addition of cytokines. The surface dependence of FBGC formation is hypothesized to be the result of varying levels of silane-derived surface carbon.

The foreign body reaction to implanted biomaterials, characterized by the presence of macrophages and foreign body giant cells (FBGC), can result in structural and functional failure of the implant. Recently, we have shown that interleukin-4 and interleukin-13 can independently induce human macrophage fusion to form FBGC via a macrophage mannose receptor (MR) -mediated pathway. The MR is believed to mediate both endocytosis of glycoproteins and phagocytosis of microorganisms, which bear terminal mannose, fucose, N-acetylglucosamine, or glucose residues. Polarization of microfilaments to closely apposed macrophage membranes as observed with fluorescence confocal microscopy led us to ask whether MR-mediated fusion occurred via a filamentous actin-dependent pathway. Cytochalasins B and D and latrunculin-A, agents that disrupt microfilaments, inhibited macrophage fusion in a concentration-dependent manner. The concentrations of cytochalasins D and B that inhibited fusion did not significantly decrease macrophage adhesion, spreading, or motility but did inhibit internalization of Candida albicans during interleukin-13-enhanced, MR-mediated phagocytosis. Very low concentrations of cytochalasin B (< 2 microM) induced a slight enhancement of macrophage fusion. Taken together, the results of this study suggest that cytokine-induced, MR-mediated macrophage fusion requires an intact F-actin cytoskeleton and that the mechanism of fusion is similar to phagocytosis.--DeFife, K. M., Jenney, C. R., Colton, E., Anderson, J. M. Disruption of filamentous actin inhibits human macrophage fusion.