Hanseniaspora guilliermondii and Hanseniaspora uvarum were tested in grape must fermentations as pure and mixed starter cultures with Saccharomyces cerevisiae. In pure cultures, the specific growth rates found were 0.29 h(-1) for H. uvarum, 0.23 h(-1) for H. guilliermondii and 0.18 h(-1) for S. cerevisiae. No significant differences were observed between these values and those obtained in mixed cultures. Results presented in this work show that growth of apiculate yeasts during the first days of fermentation enhances the production of desirable compounds, such as esters, and may not have a negative influence on the production of higher alcohols and undesirable heavy sulphur compounds. Growth of apiculate yeasts reduced the total content of higher alcohols in wines, when compared to those produced by a pure culture of S. cerevisiae. Furthermore, the highest levels of 2-phenylethyl acetate were obtained when H. guilliermondii was inoculated in grape musts, whereas H. uvarum increased the isoamyl acetate content of wines. Apiculate yeasts produced high amounts of ethyl acetate; however, the level of this compound decreased in mixed cultures of apiculate yeasts and S. cerevisiae. When S. cerevisiae was used as a starter culture, wines showed higher concentrations of glycerol, 2-phenylethanol and ethyl hexanoate. In mixed cultures of apiculate yeasts and S. cerevisiae, wines presented amounts of methionol, acetic acid-3-(methylthio)propyl ester, 4-(methylthio)-1-butanol, 2-mercaptoethanol and cis-2-methyltetrahydro-thiophen-3-ol similar to those produced by a pure culture of S. cerevisiae. An increase in the amounts of 3-(ethylthio)-1-propanol, trans-2-methyltetrahydro-thiophen-3-ol and 3-mercapto-1-propanol was obtained in wines produced from mixed cultures with H. guilliermondii.

Strains of Hanseniaspora uvarum, Hanseniaspora guilliermondii and Saccharomyces cerevisiae were used as pure or mixed starter cultures in commercial medium, in order to compare their kinetic parameters and fermentation patterns. In pure and mixed cultures, yeasts presented similar ethanol yield and productivity. Pure cultures of H. uvarum and S. cerevisiae showed a specific growth rate of 0.38 h(-1); however, this value decreased when these yeasts were grown in mixed cultures with H. guilliermondii. The specific growth rate of pure cultures of H. guilliermondii was 0.41 h(-1) and was not affected by growth of other yeasts. H. guilliermondii was found to be the best producer of 2-phenylethyl acetate and 2-phenylethanol in both pure and mixed cultures. In pure cultures, H. uvarum led to the highest contents of heavy sulphur compounds, but H. guilliermondii and S. cerevisiae produced similar levels of methionol and 2-methyltetrahydrothiophen-3-one. Growth of apiculate yeasts in mixed cultures with S. cerevisiae led to amounts of 3-methylthiopropionic acid, acetic acid-3-(methylthio)propyl ester and 2-methyltetrahydrothiophen-3-one similar to those obtained in a pure culture of S. cerevisiae; however, growth of apiculate yeasts increased methionol contents of fermented media.

The influence of nitrogen compounds in grape musts on the content of sulphur compounds of wines was studied. Different vinifications were performed with the addition of methionine (20 mg l −1) and/or cysteine (40 mg l −1) to grape musts before alcoholic fermentation. Six grape musts, with different nitrogen composition, from cultivars of the 'Vinhos Verdes' Region, in Portugal, were used. Addition of methionine to grape musts enhanced the content of wines in 3-(methylthio)-1-propanol, acetic acid-3-(methylthio)propyl ester, 3-(methylthio)propionic acid and some unidentified sulphur compounds. Increase of cysteine concentration in musts led to the production of wines with high levels of hydrogen sulphide and cis-2-methyltetrahydrothiophene-3-OL and also unidentified sulphur compounds; however, the content of 3-(methylthio)propionic acid in the wines decreased considerately with the addition of cysteine to grape musts. This work showed that cultivars from the Vinho Verde Region show different sulphur compound contents. Avesso wines, elaborated from grape musts with low amino acids level, presented the highest total sulphur compounds content. Wines from Azal branco and Alvarinho were characterised by high contents of 4-(methylthio)-1-butanol and 3-(methylthio)propionic acid, respectively. A high content of N-(3-(methylthio) propyl)-acetamide and dimethylsulphone characterise the Loureiro wines. In contrast, Trajadura wines, produced from a must rich in amino acids, presented a low total sulphur compounds content; however, these wines were also characterised by high concentrations of 4-(methylthio)-1-butanol, acetic acid-3-(methylthio)propyl ester and hydrogen sulphide.

Clostridium butyricum is to our knowledge the best natural 1,3-propanediol producer from glycerol and the only microorganism identified so far to use a coenzyme B12-independent glycerol dehydratase. However, to develop an economical process of 1,3-propanediol production, it would be necessary to improve the strain by a metabolic engineering approach. Unfortunately, no genetic tools are currently available for C. butyricum and all our efforts to develop them have been so far unsuccessful. To obtain a better "vitamin B12-free" biological process, we developed a metabolic engineering strategy with Clostridium acetobutylicum. The 1,3-propanediol pathway from C. butyricum was introduced on a plasmid in several mutants of C. acetobutylicum altered in product formation. The DG1(pSPD5) recombinant strain was the most efficient strain and was further characterized from a physiological and biotechnological point of view. Chemostat cultures of this strain grown on glucose alone produced only acids (acetate, butyrate and lactate) and a high level of hydrogen. In contrast, when glycerol was metabolized in chemostat culture, 1,3-propanediol became the major product, the specific rate of acid formation decreased and a very low level of hydrogen was observed. In a fed-batch culture, the DG1(pSPD5) strain was able to produce 1,3-propanediol at a higher concentration (1104 mM) and productivity than the natural producer C. butyricum VPI 3266. Furthermore, this strain was also successfully used for very long term continuous production of 1,3-propanediol at high volumetric productivity (3 g L-1 h-1) and titer (788 mM).

Clostridium acetobutylicum is not able to grow on glycerol as the sole carbon source since it cannot reoxidize the excess of NADH generated by glycerol catabolism. Nevertheless, when the pSPD5 plasmid, carrying the NADH-consuming 1,3-propanediol pathway from C. butyricum VPI 3266, was introduced into C. acetobutylicum DG1, growth on glycerol was achieved, and 1,3-propanediol was produced. In order to compare the physiological behavior of the recombinant C. acetobutylicum DG1(pSPD5) strain with that of the natural 1,3-propanediol producer C. butyricum VPI 3266, both strains were grown in chemostat cultures with glycerol as the sole carbon source. The same "global behavior" was observed for both strains: 1,3-propanediol was the main fermentation product, and the qH 2 flux was very low. However, when looking at key intracellular enzyme levels, significant differences were observed. Firstly, the pathway for glycerol oxidation was different: C. butyricum uses a glycerol dehydrogenase and a dihydroxyacetone kinase, while C. acetobutylicum uses a glycerol kinase and a glycerol-3-phosphate dehydrogenase. Secondly, the electron flow is differentially regulated: (i) in C. butyricum VPI 3266, the in vitro hydrogenase activity is 10-fold lower than that in C. acetobutylicum DG1(pSPD5), and (ii) while the ferredoxin-NAD ؉ reductase activity is high and the NADH-ferredoxin reductase activity is low in C. acetobutylicum DG1(pSPD5), the reverse is observed for C. butyricum VPI 3266. Thirdly, lactate dehydrogenase activity is only detected in the C. acetobutylicum DG1(pSPD5) culture, explaining why this microorganism produces lactate.For a long time, 1,3-propanediol has been considered a specialty chemical. However, the recent development of a new polyester called poly(propylene terephthalate), with unique properties for the fiber industry (23, 29), necessitates a drastic increase in the production of this chemical. There are currently two processes for the chemical synthesis of 1,3-propanediol. Both of these processes produce toxic intermediates and require a reduction step under high hydrogen pressure (35). The biological production of 1,3-propanediol from glycerol was demonstrated for several bacterial species, e.g., Lactobacillus brevis, Lactobacillus buchnerii (32, 33), Bacillus welchii (15), Citrobacter freundii, Klebsiella pneumoniae (14, 34), Clostridium pasteurianum (7), and Clostridium butyricum (2, 13, 31). Among these microorganisms, C. butyricum is, to our knowledge, the best "natural producer" in terms of both the yield and titer of 1,3-propanediol produced (30). Moreover, unlike the case with other bacteria, the production of 1,3-propanediol by this microorganism is not a vitamin B 12 -dependent process, which is clearly an economical advantage for an industrial application. The B 12 -independent pathway converting glycerol to 1,3-propanediol in C. butyricum has been recently characterized from a biochemical (31) and a molecular point of view (27). To develop an economical process of 1,3-propanediol production, it...