Introduction: Campylobacteriosis is considered the most common bacteria-caused human gastroenteritis in the world. Poultry is a major reservoir of Campylobacter. Human infection may occur by consumption of raw and undercooked poultry or by contamination of other foods by these items. The aim of this study was to assess the prevalence of Campylobacter spp. in poultry processing plants with conventional culture method and real-time PCR. Methodology: A total of 108 poultry processing plant samples were collected to test with conventional microbiology and qPCR. Sampling included cloacal swabs, swabs of transport crates (before and after the cleaning and disinfection process) and carcasses (after the chiller, cooled at 4°C and frozen at −12°C). Results: Positivity in cloacal swabs indicated that poultry arrived contaminated at the slaughterhouse. Contamination in transport cages was substantially increased after the cleaning process, indicating that the process was ineffective. The detection of Campylobacter on carcasses was higher than that on cloacal swabs, which could indicate cross-contamination during the slaughtering process. Conventional microbiology and molecular methods revealed a prevalence of 69.4% and 43.5%, respectively. Lower detection by qPCR can be attributed to the high specificity of the kit and to biological components that could inhibit PCR reactions. Conclusions: Our results indicate that poultry arrive contaminated at the slaughterhouse and that contamination can increase during the slaughtering process due to cross-contamination. The isolation of Campylobacter in cooled and frozen carcasses corroborates the bacterial survival even at temperatures considered limiting to bacterial growth which are routinely used for food preservation.

Introduction: Salmonella is a major cause of foodborne illness throughout the world. The use of quantitative techniques is important for assessing the risk and determining the capacity of each step of the slaughtering process to decrease or increase bacterial contamination. We aimed to detect and to quantify the presence of Salmonella in Brazilian processing plants by real-time quantitative polymerase chain reaction (qPCR). Methodology: A total of 139 poultry slaughterhouses samples were collected in order to detect to and quantify Salmonella by qPCR. Results: Almost all collection points (3/18), except water from pre-chiller tank, carcasses after pre-chiller, and carcasses frozen at -12ºC for 60 days, and 49% (68/139) of samples were positive for Salmonella. Quantification means varied equally among all of the tested sources, and we could not establish any pattern of variation. A large proportion (52.6%) of cloacal swabs was Salmonella-positive. Also, contamination in transport cages was increased after the cleaning process, indicating that the process was ineffective. The overall prevalence in samples obtained during the slaughtering process was 48.9%, and on the whole rinsed carcasses, this proportion was 50%. The detection of Salmonella in frozen carcasses, even after long periods of storage, indicates that the carcasses are a potential source of infection for consumers. Conclusions: We found that contamination levels remain similar throughout the slaughtering. qPCR proved to be an efficient method for the detection of Salmonella.

Background: Salmonella spp. are frequently isolated from fowls, and their detection in poultry products varies according to the breeding system and the slaughtering process, bringing risks to the consumer and compromising the marketability. The control of Salmonella in poultry slaughterhouses is based on the detection of bacteria, but the quantification of the agent would be important in assessing risk, as well as in obtaining data to determine the capacity of each step of the process to decrease or increase bacterial contamination. The aims of this study were to propose a method for the quantification of Salmonella in poultry slaughterhouses, frequency of isolation and serovars identified.Materials, Methods & Results: Twenty-one broiler flocks from seven federally inspected slaughterhouses in southern Brazil, totaling 1,071 samples, were assessed by miniaturized most probable number (mMPN) and conventional microbiology. The samples were collected in triplicate at 17 points, which included cloacae, transportation cages before and after sanitization, water (scald tank, supply, pre-chiller and chiller), and carcasses (before and after scalding, defeathering, rinsing, evisceration, final rinsing, chilling at 4ºC, and freezing at -12°C for 24 h, 30 and 60 days). Typical Salmonella colonies were submitted to TSI, LIA, SIM, urea, and polyvalent anti-O antiserum tests, and to final identification by Microarray by Check&Trace. Nine of the 1,071 (0.83%) samples analyzed by mMPN and by conventional microbiology were positive for Salmonella and the following serovars were identified: Anatum, Brandenburg, Agona, Tennessee, Bredeney, Schwarzengrund and Infantis.Discussion: This positive rate was lower than that described by other authors, whose rates ranged from 3% and 39% for the isolation of Salmonella spp. from different sources, such as slaughterhouses and retail sales in samples collected in Brazil. The low frequency of isolation of Salmonella in this study can be attributed to the efficiency of control systems used from the field to the slaughterhouse, such as Good Manufacturing Practices (GMP) and Sanitation Standard Operating Procedures (SSOP), which are HACCP requirements. Also, when slaughtering technology actions are properly managed, such as water replacement and temperatures lower than 4ºC in the chiller, the initial contamination by Salmonella spp. can be reduced, with a decline in contamination from 70% to 20%, and with a reduction in the contamination of broiler carcasses after chilling from 15.8% to 3.3%. On the other hand the contamination of carcasses by Salmonella before pre-chilling and in post-chilling might be due to the automated system, inadequate temperatures during chilling, and inappropriate water chlorination in the assessed meat-packing plant. Of the 17 points evaluated, seven were positive for Salmonella, especially the cages after sanitization and frozen carcasses. The contamination by Salmonella spp. in transportation cages after sanitization indicates inefficiency of the automated system as well as possible bacterial resistance to the sanitizers used in SSOP while the isolation in carcasses frozen for 24 h and 60 days demonstrates the thermal resistance of the bacterium to a conservation method widely used in the food industry. In this work, just one of the nine positive samples for Salmonella was identified by conventional methods (CM) and mMPN. The discrepancy between methods can be explained by the heterogeneous distribution of Salmonella and other bacteria in naturally contaminated samples. Samples that were positive in the qualitative test but negative in the mMPN protocol could have had a number of Salmonella below the detection amount.

ResumoEspécies de Campylobacter spp. termotolerantes são agentes de surtos de campilobacteriose em humanos e os produtos de origem avícola são considerados uma importante fonte de infecção. Foram identificados Campylobacter jejuni e Campylobacter coli em carcaças de frango resfriadas e congeladas coletadas em três abatedouros entre 2014 e 2015. A detecção de Campylobacter spp. foi realizada por microbiologia convencional e a identificação de C. jejuni e C. coli por multiplex-PCR. Dentre as amostras avaliadas verificou-se Campylobacter spp. termotolerante em 63,8%, sendo 72,2% em carcaças resfriadas e 55,5% em carcaças congeladas. Destas, 83,3% foram positivas para C. jejuni e 66,6% para C. coli, enquanto 50% foram positivas para ambas as espécies. A presença de Campylobacter spp. termotolerante em carcaças de frangos de corte prontas para consumo representa uma importante fonte de transmissão destes patógenos para humanos. Palavras-chave: abatedouros avícolas; campilobacteriose; termotolerantes. AbstractSpecies of thermophilic Campylobacter spp. are agents of campylobacteriosis outbreaks in humans, and poultry products are implicated as major sources of infection. The detection of Campylobacter spp. was performed by conventional microbiology in poultry carcasses collected in slaughterhouses and species were identified by multiplex-PCR. Thermophilic Campylobacter spp. was verified in 63.8% of the samples, being 72.2% in chilled carcasses and 55.5% in frozen carcasses. Of these, 83.3% were positive for C. jejuni and 66.6% to C. coli, while 50% were positive for both. The presence of thermophilic Campylobacter spp. in ready-to-eat poultry products represents a potential source of human campylobacteriosis.