An experimental system investigating condensation heat transfer of wet flue gas was set up and the heat transfer performance of vapor-gas mixture with vapor condensation was discussed. The experimental results of laminar flow in a plastic longitudinal spiral plate heat exchanger were obtained and are in good agreement with the modified classical film model. It is shown that the plastic air preheater can avoid acid corrosion in the low-temperature field for the boiler using fuel containing sulfur and recover latent heat of the water vapor of the wet flue gas. Also some SO2 was scrubbed during the vapor condensing process in the heat exchanger.

No abstract

No abstract

The experiment was conducted to investigate the heat transfer performance of wet flue gas in a vertical tube. The factors influencing the convective condensation of wet flue gas were experimentally investigated. The measured results indicate that the convective heat transfer of bulk flow and condensation heat transfer of vapor have significant contribution to the total heat transfer and the dominant transport mechanism is dependent upon the vapor fraction in mixture. keywords: latent heat, recovery, exhaust flue gas.

The convection-condensation heat transfer of vapor-gas mixtures in a vertical tube was studied theoretically and experimentally. The effects of the condensation of a small amount of water vapor (8 to 20%) on heat transfer in a vertical tube were discussed. Comparisons show that theoretical solutions obtained through modified film model and experimental results are in good agreement. The results show that the condensation heat transfer of a small amount of water vapor and single-phase convection heat transfer in the vapor-gas mixtures are of the same order of magnitude, and these two modes of heat transfer could not be neglected.