The aim of this study was to investigate the effect of two-stage variable temperature drying (VTD) on the quality and drying efficiency of paddy rice in the hot air-drying process. A constant temperature of 50 °C (CTD) was used as a control group. VTD and CTD methods were applied in a 15 ton batch type recirculating grain dryer. Three aspects (appearance quality, physical and chemical properties, taste quality) of the paddy rice samples from the dryer were measured and compared. It was observed that paddy rice with an initial moisture content of 25.3% (wet basis) was dried to 14% (wet basis). Compared to CTD, the VTD method could reduce the drying time and fissuring rate by 0.7 h and 42%, respectively. It had a head rice yield (HRY) of 78.45%, compared to 76.45% by CTD. The fatty acid content of the VTD samples was 2.28% lower than those of CTD, and it exhibited a 34% decrease in amylose content. These results show that two-stage VTD is an advanced hot air-drying method that can be used to improve the quality of dried paddy rice, maintain efficiency, and reduce the cost of the drying process by minimizing the rate of energy consumption.

Aspergilus flavus is the main pathogenic fungus that causes food mold. Effective control of A. flavus contamination is essential to ensure food safety. The lipopeptides (LPs) produced by Bacillus strains have been shown to have an obvious antifungal effect on molds. In this study, an antagonist strain of Bacillus velezensis with obvious antifungal activity against A. flavus was isolated from the surface of healthy rice. Using HPLC-MS analysis, the main components of LPs produced by strain E2 were identified as fengycin and iturins. Further investigations showed that LPs could inhibit the spore germination, and even cause abnormal expansion of hyphae and cell rupture. Transcriptomic analyses showed that some genes, involved in ribosome biogenesis in eukaryotes (NOG1, KRE33) and aflatoxin biosynthesis (aflK, aflR, veA, omtA) pathways in A. flavus were significantly down-regulated by LPs. In conclusion, this study provides novel insights into the cellular and molecular antifungal mechanisms of LPs against grain A. flavus contamination.