The first successful expression of the Aequorea victoria green fluorescent protein (GFP) gene in Aspergillus niger is described. When the wild-type GFP gene was expressed in A. niger, neither the fluorescence nor the full translation product of the wtGFP gene was detectable. However, the expression of a mutant form of the green fluorescent protein (S65TGFP) gene resulted in the formation of a functional fluorescent polypeptide. The synthesis of S65TGFP was used to study glaA promoter controlled heterologous gene expression by recombinant A. niger in batch and fed-batch cultures using a defined growth medium. Cells were grown on xylose as noninducing carbon source, and the production of S65TGFP was accomplished by the addition of maltose. The recombinant protein accumulated up to 10 or 25 mg of S65TGFP g-1 cell dry weight using either a maltose pulse for induction or continuous addition of the inducing carbon source, respectively. Irrespective of the induction protocol, the recombinant protein started to accumulate 2 h after addition of the inducing carbon source and reached its maximum specific concentration 10 h after induction. Bright green fluorescing fungal pellets were first detectable by fluorescence microscopy 4-5 h after the onset of maltose addition.

CitationIn-depth analysis of the Aspergillus niger glucoamylase (glaA) promoter performance using high-throughput screening and controlled bioreactor cultivation techniques. However, induction of the glaA expression system through the monosaccharide glucose is significantly lower compared to starch and the higher molecular weight starch degradation products. All other 26 carbon substrates tested do not induce, or even, as in the case of the easily metabolizable monosaccharide xylose, repress glaA-promoter controlled gene expression in the presence of the inducing disaccharide maltose with an increase of repression strength by increasing xylose concentrations. The complex effect of glucose on glaA-promoter controlled expression was also analyzed using non-metabolizable glucose analogs, namely 5-thio-glucose and 2-deoxyglucose, which were identified as novel and potent inducers of the glaA expression system. The results show that the induction strength depends on the inducer concentration with a maximum at defined concentrations and lower induction or even repression at concentrations above. Moreover, controlled fed-batch cultivations using a high maltose feed rate with concomitant extracellular accumulation of glucose resulted in lower levels of the reporter protein compared to cultures with a low maltose feed rate without extracellular glucose accumulation, thus supporting the conclusion that increasing the glucose concentration beyond a critical point reduces the induction strength or may even cause repression. This way, the speed of polymer hydrolysis, glucose uptake and intracellular breakdown can be fine-tuned for optimal fungal growth and the metabolic burden for glucoamylase synthesis can be limited adequately in response to nutrient availability.-3 -

The production of a mutant green fluorescent protein (S65TGFP), controlled by the maltose inducible glucoamylase promoter, was followed in situ in fed-batch cultures of recombinant Aspergillus niger using multi-wavelength fluorescence spectroscopy. Disturbance of quantitative product analysis by interfering fluorescence signals was resolved by using a set of defined combinations of excitation and emission wavelengths (lambda(ex)/lambda(em)). This technique resulted in excellent linearity between on-line signal and off-line determined S65TGFP concentrations. Spore germination was detectable in situ by monitoring the back scattered light intensity. Moreover, flavin-like fluorophores were identified as the dominating fungal host fluorophores. The time-dependent intensity of this fluorophore, potentially fungal flavin-containing oxidoreductase(s), did not correlate with the biomass concentration but correlated well with the fungal metabolic activity (e.g. respiratory activity). Other fluorophores commonly found in microbial cultures such NADH, pyridoxine and the aromatic amino acids, tryptophan, phenylalanine and tyrosine did not contribute significantly to the culture fluorescence of A. niger. Thus, multi-wavelength fluorescence spectroscopy has proven to be an effective tool for simultaneous on-line monitoring of the most relevant process variables in fungal cultures, e.g. spore germination, metabolic activity, and quantitative product formation.

BackgroundPichia pastoris is a widely-used host for recombinant protein production; expression is typically driven by methanol-inducible alcohol oxidase (AOX) promoters. Recently this system has become an important source of recombinant G protein-coupled receptors (GPCRs) for structural biology and drug discovery. The influence of diverse culture parameters (such as pH, dissolved oxygen concentration, medium composition, antifoam concentration and culture temperature) on productivity has been investigated for a wide range of recombinant proteins in P. pastoris. In contrast, the impact of the pre-induction phases on yield has not been as closely studied. In this study, we examined the pre-induction phases of P. pastoris bioreactor cultivations producing three different recombinant proteins: the GPCR, human A2a adenosine receptor (hA2aR), green fluorescent protein (GFP) and human calcitonin gene-related peptide receptor component protein (as a GFP fusion protein; hCGRP-RCP-GFP).ResultsFunctional hA2aR was detected in the pre-induction phases of a 1 L bioreactor cultivation of glycerol-grown P. pastoris. In a separate experiment, a glycerol-grown P. pastoris strain secreted soluble GFP prior to methanol addition. When glucose, which has been shown to repress AOX expression, was the pre-induction carbon source, hA2aR and GFP were still produced in the pre-induction phases. Both hA2aR and GFP were also produced in methanol-free cultivations; functional protein yields were maintained or increased after depletion of the carbon source. Analysis of the pre-induction phases of 10 L pilot scale cultivations also demonstrated that pre-induction yields were at least maintained after methanol induction, even in the presence of cytotoxic concentrations of methanol. Additional bioreactor data for hCGRP-RCP-GFP and shake-flask data for GFP, horseradish peroxidase (HRP), the human tetraspanins hCD81 and CD82, and the tight-junction protein human claudin-1, demonstrated that bioreactor but not shake-flask cultivations exhibit recombinant protein production in the pre-induction phases of P. pastoris cultures.ConclusionsThe production of recombinant hA2aR, GFP and hCGRP-RCP-GFP can be detected in bioreactor cultivations prior to methanol induction, while this is not the case for shake-flask cultivations of GFP, HRP, hCD81, hCD82 and human claudin-1. This confirms earlier suggestions of leaky expression from AOX promoters, which we report here for both glycerol- and glucose-grown cells in bioreactor cultivations. These findings suggest that the productivity of AOX-dependent bioprocesses is not solely dependent on induction by methanol. We conclude that in order to maximize total yields, pre-induction phase cultivation conditions should be optimized, and that increased specific productivity may result in decreased biomass yields.Electronic supplementary materialThe online version of this article (doi:10.1186/s12934-014-0127-y) contains supplementary material, which is available to authorized users.