Phenylalanine and tyrosine ammonia-lyases form cinnamic acid and p-coumaric acid, which are precursors of a wide range of aromatic compounds of biotechnological interest. Lack of highly active and specific tyrosine ammonia-lyases has previously been a limitation in metabolic engineering approaches. We therefore identified 22 sequences in silico using synteny information and aiming for sequence divergence. We performed a comparative in vivo study, expressing the genes intracellularly in bacteria and yeast. When produced heterologously, some enzymes resulted in significantly higher production of p-coumaric acid in several different industrially important production organisms. Three novel enzymes were found to have activity exclusively for phenylalanine, including an enzyme from the low-GC Gram-positive bacterium Brevibacillus laterosporus, a bacterial-type enzyme from the amoeba Dictyostelium discoideum, and a phenylalanine ammonia-lyase from the moss Physcomitrella patens (producing 230 M cinnamic acid per unit of optical density at 600 nm [OD 600 ]) in the medium using Escherichia coli as the heterologous host). Novel tyrosine ammonia-lyases having higher reported substrate specificity than previously characterized enzymes were also identified. Enzymes from Herpetosiphon aurantiacus and Flavobacterium johnsoniae resulted in high production of p-coumaric acid in Escherichia coli (producing 440 M p-coumaric acid OD 600 unit ؊1 in the medium) and in Lactococcus lactis. The enzymes were also efficient in Saccharomyces cerevisiae, where p-coumaric acid accumulation was improved 5-fold over that in strains expressing previously characterized tyrosine ammonia-lyases. Small organic molecules of biotechnological interest include aromatic structures that are derived from p-coumaric acid (pHCA). pHCA can be formed from phenylalanine either through deamination to cinnamic acid (CA) by phenylalanine ammonialyase (PAL; EC 4.3.1.24) and subsequent hydroxylase activity by trans-cinnamate-4-monooxygenase or through deamination of tyrosine by tyrosine ammonia-lyase (TAL; EC 4.3.1.23) (Fig. 1). Considering that the route from phenylalanine requires activity of a P450 enzyme, which has been shown to be the limiting step in previous engineering strategies (1, 2), deamination of tyrosine for production of pHCA may be preferred in microbial cell factories. Tyrosine ammonia-lyases (TAL) have been employed for the production of plant biochemicals and aromatic compounds, e.g., for pHCA itself (3-5), or in the production of stilbenes, such as resveratrol (6, 7), flavonoids, such as naringenin (8, 9), cinnamoyl anthranilates (10), or plastic precursors, such as p-hydroxystyrene (11, 12), yet the TAL reaction may be the limiting step (10, 13).Due to the significant interest in production of phenolic compounds in biotechnological processes, we aimed at increasing the range of characterized phenylalanine ammonia-lyases (PAL) and tyrosine ammonia-lyases (TAL), and in particular at identifying the optimal TAL for use in microbial cell factories...

No abstract

Mannitol is a sugar polyol claimed to have health-promoting properties. A mannitol-producing strain of Lactococcus lactis was obtained by disruption of two genes of the phosphoenolpyruvate (PEP)-mannitol phosphotransferase system (PTS Mtl ). Genes mtlA and mtlF were independently deleted by double-crossover recombination in strain L. lactis FI9630 (a food-grade lactate dehydrogenase-deficient strain derived from MG1363), yielding two mutant (⌬ldh⌬mtlA and ⌬ldh⌬mtlF) strains. The new strains, FI10091 and FI10089, respectively, do not possess any selection marker and are suitable for use in the food industry. The metabolism of glucose in nongrowing cell suspensions of the mutant strains was characterized by in vivo 13 C-nuclear magnetic resonance. The intermediate metabolite, mannitol-1-phosphate, accumulated intracellularly to high levels (up to 76 mM). Mannitol was a major end product, one-third of glucose being converted to this hexitol. The double mutants, in contrast to the parent strain, were unable to utilize mannitol even after glucose depletion, showing that mannitol was taken up exclusively by PEP-PTS Mtl . Disruption of this system completely blocked mannitol transport in L. lactis, as intended. In addition to mannitol, approximately equimolar amounts of ethanol, 2,3-butanediol, and lactate were produced. A mixed-acid fermentation (formate, ethanol, and acetate) was also observed during growth under controlled conditions of pH and temperature, but mannitol production was low. The reasons for the alteration in the pattern of end products under nongrowing and growing conditions are discussed, and strategies to improve mannitol production during growth are proposed.Mannitol, a six-carbon sugar polyol, is synthesized by many eukaryotes and a few bacteria, but apparently not by archaea. Mannitol is also a well-known compatible solute that accumulates mainly in yeast, fungi, and plants, but rarely in bacteria, in response to osmotic and/or heat stresses (5,16,21,23). Like several other compatible solutes, mannitol protects proteins and cells against different stressing conditions. Recently, its ability to enhance survival of starter cultures of Lactococcus lactis subjected to drying has been demonstrated (6).Mannitol is assumed to have several health-promoting properties; thus the enrichment of foods with mannitol by in situ production during fermentation could be a positive, clean strategy to obtain healthier fermented food products. In the human gut, mannitol can be converted to short-chain fatty acids (such as butyrate), which have been claimed to confer protection against the development of colon cancer (42). Moreover, mannitol is a scavenger of hydroxyl radicals and a low-calorie sweetener that is partially and slowly absorbed in the small intestine (8,40).Lactic acid bacteria (LAB) are a group of microorganisms widely used as starter cultures in dairy fermentations. Hence, these food-associated organisms could be ideal agents for the in situ production of mannitol in foods. The ability of heterofermenta...