No abstract

Formation of microbial biofilms and slimes is a general and serious problem in the operation of paper machines. Studies of microbial populations in paper machine-derived biofilms have been conducted using standard microbiological procedures; however, the bacterial genera present in this type of samples as well as their diversity are quite poorly known. Here, the bacterial diversity of 38 process water and 22 biofilm samples from four different Finnish paper machines were analyzed by length heterogeneity analysis of PCR-amplified 16S ribosomal DNA (LH-PCR). In addition, sequencing of the amplified 16S rRNA gene from 69 clones was conducted for characterization of the bacterial genera present in biofilm and slime samples. The LH-PCR profiles of both the free-living (process waters) and immobilized (biofilms) bacteria were diverse at all stages of the papermaking process. Out of the 69 sequenced clones, 44 belonged to alpha-Proteobacteria, most of which were close to the nitrogen-fixing root nodule genera Sinorhizobium, Rhizobium and Azorhizobium. Other clones were assigned to beta- and gamma-Proteobacteria and the phylum Bacteroidetes. In addition, eight of the clones were assigned to a yet uncultivated phylum, TM7. Finally, epifluorescence microscopy revealed that Gram-negative bacteria were predominant in both the biofilm (65%) and process water (54%) samples and a small coccoid cell morphology was most common in all samples. Together, our results show that the analysis of microbial samples from paper machines using modern molecular biology techniques adds valuable information and should, therefore, be useful as a more specific and sensitive microbiological method for the paper industry. This information could further be applied, e.g., in the development of more specific and environmental friendly antimicrobial agents for paper mills.

No abstract

Formation of biofilms causes severe problems in paper machines, and hence financial costs. It would be preferable to prevent attachment of the primary-colonizing bacteria than to control the growth of secondary communities, which are sheltered by exopolysaccharide slime layers. We have therefore investigated the early succession of paper-machine biofilms by incubating stainless-steel test coupons in the process water-flow lines in two paper machines operating in slightly alkaline conditions in temperatures (45 and 49 degrees C) supporting thermophilic microbes. Microbial succession was profiled using length heterogeneity analysis of PCR-amplified 16S rRNA genes (LH-PCR) and linking the sequence data of the created 16S rRNA gene libraries to the dominant LH-PCR peaks. Although the bacterial fingerprints obtained from the attached surface communities varied slightly in different samples, the biomarker signals of the dominating primary-colonizing bacterial groups remained high over time in each paper machine. Most of the 16S rRNA gene copies in the early biofilms were assigned to the genera Rhodobacter, Tepidimonas, and Cloacibacterium. The dominance of these sequence types decreased in the developing biofilms. Finally, as phylogenetically identical primary-colonizers were detected in the two different paper mills, the machines evidently had similar environmental conditions for bacterial growth and potentially a common source of contamination.

Fluorescence correlation spectroscopy (FCS) was used in monitoring human parvovirus B19 virus-like particle (VLP) antibody complexes from acute phase and past-immunity serum samples. The Oregon Green 488-labeled VLPs gave an average diffusion coefficient of 1.7 x 10(-7) cm2 s(-1) with an apparent hydrodynamic radius of 14 nm. After incubation of the fluorescent VLPs with an acute phase serum sample, the mobility information obtained from the fluorescence intensity fluctuation by autocorrelation analysis showed an average diffusion coefficient of 1.5 x 10(-8) cm2 s(-1), corresponding to an average radius of 157 nm. In contrast, incubation of the fluorescent VLPs with a past-immunity serum sample gave an average diffusion coefficient of 3.5 x 10(-8) cm2 s(-1) and a radius of 69 nm. A control serum devoid of B19 antibodies caused a change in the diffusion coefficient from 1.7 x 10(-7) to 1.6 x 10(-7) cm2 s(-1), which is much smaller than that observed with acute phase or past-immunity sera. Thus, VLP-antibody complexes with different diffusion coefficients could be identified for the acute phase and past-immunity sera. FCS measurement of VLP-immune complexes could be useful in distinguishing between antibodies present in acute phase or past-immunity sera as well as in titration of the VLPs.