When assessing the performance of an internal quality control system, it is useful to determine the probability for false rejections (pfr) and the probability for error detection (ped). These performance characteristics are estimated here by use of a computer stimulation procedure. The control rules studied include those commonly employed with Shewhart-type control charts, a cumulative sum rule, and rules applicable when a series of control measurements are treated as a single control observation. The error situations studied include an increase in random error, a systematic shift, a systematic drift, and mixtures of these. The probability for error detection is very dependent on the number of control observations and the choice of control rules. No one rule is best for detecting all errors, thus combinations of rules are desirable. Some appropriate combinations are suggested and their performance characteristics are presented.

No abstract

We have measured plasma concentrations of local anaesthetics, and the substance fraction of methaemoglobin (MetHb), in infants less than 3 months of age, after application of a lignocaine-prilocaine cream (EMLA). A total of EMLA 2 g was applied over four different skin areas, totalling 16 cm2, for 4 h before anaesthesia for a minor surgical procedure. Sampling was carried out before and 4, 8 and 12 h after application. Maximum MetHb values (median = 2.24%) were obtained usually at 8 h and were significantly (P less than 0.001) higher than before application (median 1.32%). The plasma concentrations of local anaesthetics were low (maximum values: prilocaine 78 ng ml-1, lignocaine 412 ng ml-1). The activity of erythrocyte MetHb reductase (cytochrome b5 reductase) was analysed. Data from a previously studied group of infants aged 3-12 months were included also. Enzyme activity did not reach adult levels until after the age of 3 months. It showed a good inverse correlation with the maximum MetHb values after application of EMLA. Although the MetHb concentrations in the infants younger than 3 months were small, the enzyme capacity may be overloaded when EMLA is administered at the same time as other MetHb-inducing agents. It is concluded that the use of EMLA should be restricted in this age group.

We describe the adaptation of the decision limit cumulative sum method (cusum) to internal quality control in clinical chemistry. With the decision limit method, the cusum is interpreted against a numerical limit, rather than by use of a V-mask. The method can be readily implemented in computerized quality-control systems or manually on controls charts. We emphasize the manual application here and demonstrate how the technique can be implemented on existing Shewhart or Levey-Jennings control charts. This permits both cusum and Shewhart control rules to be used simultaneously on a single control chart and also minimizes the data calculations necessary for the cusum method. Computer simulation studies are used to determine the performance characteristics of several different cusum rules, alone and in combination with a Shewhart rule. These studies indicate that improvements in existing quality-control systems should be possible by addition of this simple cusum method and by use of a combined Shewhart-cusum control chart. This should be particularly advantageous when introducing the cusum method in laboratories with manual quality-control systems.

No abstract