No abstract

Methane production characteristics of anaerobic co-digestion of pig manure (PM) and fermented liquid feed (FLF) were investigated in a continuous digester under mesophilic conditions. The experiment followed three phases. PM alone was digested in phase I. In phases II and III, PM and FLF were mixed in a ratio of 95:5 and 90:10 (% v/v), respectively. The specific methane yields (SMYs) during phases I, II, and III were 238, 278, and 326.8 mLCH4·gVS−1-added, respectively. It was due to the effect of balancing the feedstock carbon-to-nitrogen ratio by adding FLF. This improvement can also be attributed to the readily biodegradable compounds in the FLF. The higher SMY obtained in this study showed a positive synergistic effect in the anaerobic co-digestion of PM and FLF. The results also indicate that adding the FLF positively affected and maintained a constant pH level, avoiding volatile fatty acid accumulation and ammonia inhibition in the anaerobic digestion (AD). Thus, this study provides valuable information regarding the usage of unused or wasted FLF as a co-substrate for the practical AD of PM. The production of fermented liquid additives such as FLF to improve the methane production from the AD of PM is a potential novel alternative to food waste recycling in Japan, besides compost and animal feeding.

Durian is a kind of tropical fruits which can grow well in Indonesia. Durian is containing 60-75% shell. Durian shell could be a potential alternative to activated carbon because it contains 57.42% carbon. The aim of this research is to know the effect of contact time and  stirring speed to activated carbon adsorption capacity from durian shell with KOH and NaOH as activators. FTIR (Fourier Transform Infra Red) analysis showed the activation process effects on  absorption intensity  wavelength region and resulted in formation of C = C aromatic tape, so that the nature of the charcoal becomes more polar compared with the initial condition. Analysis using spectrophotometer UV-Vis to determine  absorbance and  final concentration of each variation of contact time and stirring speed. The results showed that the maximum adsorption capacity obtained by activation of KOH and NaOH on stirring speed of 150 rpm and a contact time of 90 minutes is equal to 3.92 mg / g and 3.8 mg / g respectively. The maximum surface area obtained by activation of KOH and NaOH during the stirring speed 130 rpm and a contact time of 120 minutes is equal to 1785.263 m2 / g and 1730.332 m2 / g respectively. The maximum surface area obtained from this research has met the standards of commercial activated carbon surface area was between 800-1800 m2/ g. Modeling pseudo second order presents a more representative adsorption data, a second order equation is based on the assumption that adsorption step is chemosorption.

The Integrated Agriculture System in Indonesia was established in 2009. By the end of 2018, 752 small-scale anaerobic digestion (AD) systems treating beef cattle manure were successfully installed. In this study, the system was studied comprehensively at the first attempt by considering the current operating conditions, the actual performance of the digester, and site-specific factors for biogas production. Compost and bio-urine were produced at approximately 0.13 t/day and 4.8 L/day, respectively. The digester produced an unstable biogas amount of 0.109 to 0.521 m3/day. However, digester in Japan produces biogas 980 m3/day. This observed difference was due to the difference in the inputs and technological peculiarities. The main purpose for installation of the AD system was also different. Producing compost and bio-urine were the aimed in Indonesia, while producing biogas and reducing sawdust usage were the target in Japan. Thus, this study suggested that monitoring and controlling the operational parameters of digester in Indonesia could increase the biogas production as a first step without installing any additional temperature controller or mixing equipment. This approach might also be useful for improving the quality of compost and bio-urine by providing stable treatment conditions.